Manuals / Land Pride / Lawn and Garden / Spreader

Land Pride PS25120 manual Storage, As Required, Maintenance and Lubrication, Roller Chains

Models: PS25120

1 52

Download 52 pages 61.96 Kb

Page 41

Section 4: Maintenance and Lubrication

Land Pride

Table of Contents

Section 4: Maintenance and Lubrication

Maintenance

Proper servicing and adjustment is the key to the long life of any implement. With careful and systematic inspection, you can avoid costly maintenance, time and repair.

7.After using your seeder for several hours, check all bolts to be sure they are tight.

8.Lubricate areas noted in the “Lubrication” section.

9.Adjust idlers to remove excess slack from chains. Clean and use chain lube on all roller chains as needed.

10.Feed cup drive sprocket should be oiled in its square bore. Move feed cup adjustment lever away from sprocket as far as possible in order to get oil back into square.

11.Always maintain proper air pressure in tires.

12.Replace any worn, damaged or illegible safety labels by obtaining new labels from your Land Pride Dealer.

13.Inspect safety chain and hardware for wear or other damage.

Storage

1.At the end of the working season or when your Primary Seeder will not be used for a long period, it is good practice to clean off any dirt or grease that may have accumulated on the seeder and any of the moving parts.

2.Be sure that the seed box is completely cleaned before storing.

3.The square bore of the feed cup drive sprocket hub should be oiled to prevent seizing. Squirt oil on to the square feed cup shaft and move feed cup adjustment lever back and forth in order to get the oil back into the square.

4.Lubricate all fittings as indicated in the following illustrations.

5.When in storage, lower the seeder with rollers on a board or hard surface and adjust the parking stand or tongue jack.

6.For seeders with front or end wheels, apply a light coat of oil to exposed cylinder rods.

7.Repaint parts where paint is worn or scratched to prevent rust.

8.Store the seeder inside if possible. Inside storage will reduce maintenance and make for a longer seeder life.

Lubrication

Lubrication Legend

	Multi-purpose	Multi-purpose	Multi-purpose	50
	spray lube	grease lube	oil lube

Intervals in hours at which lubrication is required

12227

As

Required

Roller Chains

Type of Lubrication: Chain Lube

Quantity = As required. Do not overlubricate.

8/21/06

PS25120 Primary Seeder 313-156M 39

Image 41

Land Pride PS25120 manual Storage, As Required, Maintenance and Lubrication, Roller Chains, Table of Contents

Contents

PS25120 Table of ContentsPrimary Seeder Operator’s ManualImportant Safety Information Table of ContentsSection 1 Assembly and Set-up Section 4 Maintenance and LubricationLook For The Safety Alert Symbol Safety at All TimesTable of Contents Important Safety InformationUse A Safety Chain Use Safety Lights and DevicesPractice Safe Maintenance Transport Machinery SafelyWear Protective Equipment Prepare for EmergenciesAvoid High Pressure Fluids Hazard Keep Riders Off Machinery818-003C Safety Labels818-230C 818-230CImportant Safety Information Table of ContentsLand Pride 8/21/06Moving Parts 838-111CTable of Contents Important Safety InformationLand Pride Service Department Using This ManualApplication Owner AssistancePre-AssemblyChecklist Section 1 Assembly and Set-upSling Brackets Three-PointPrimary SeederPull-TypePrimary Seeder with End Wheels Pull-TypePrimary SeederRefer to Figure Table of ContentsSection 1: Assembly and Set-up Table of Contents6.Remove wheel arm pivot shaft from wheel bracket Refer to FigureTable of Contents Pull-TypePrimary Seeder with Front WheelsSection 1 Assembly and Set-up Refer to FigureTable of Contents Values Chart in “Section 9 Appendix” on pageSection 1 Assembly and Set-up Refer to FigureOperating Check List General DescriptionTractor Requirements Tractor 3-Point Hook-UpPull-Typeand End Wheel Units Tractor Drawbar Hook-UpFront Wheel Units Table of ContentsBleeding Hydraulic System Tractor Hydraulic Hook-UpOperating Hydraulic Lift System Transporting3-PointSeeders ParkingPull-Type,Front or End Wheel Seeders Table of ContentsAgitator Attachment Optional Seed Level IndicatorGeneral Operating Instructions Table of ContentsDrive System Section 3 AdjustmentsRoller Packing Wheels Seed Broadcasting SystemHigh Range Low RangeAg Drive Turf DriveTable of Contents Calibrating & Adjusting Seeding RateSection 3 Adjustments Seed Rate Adjustment FigureTable of Contents Seed Rate Charts for Ag DriveSection 3 Adjustments Fescue - Fine Blade, Turf Type Pounds per AcreTable of Contents Seed Rate Charts for Ag Drive ContinuedSection 3: Adjustments Kentucky Blue Grass Pounds per AcreSeed Rate Charts for Ag Drive Continued Brome Grass Seed Rate ChartTable of Contents Section 3 AdjustmentsTable of Contents Metric Seed Rate Charts for Ag DriveSection 3 Adjustments Clover - RedTable of Contents Metric Seed Rate Charts for Ag Drive ContinuedSection 3 Adjustments Fescue K-31Table of Contents Metric Brome Seed Rate ChartMetric Seed Rate Charts for Ag Drive Continued Section 3 AdjustmentsTable of Contents Seed Rate Charts for Turf DriveSection 3 Adjustments Fescue - Fine Blade, Turf Type Pounds per AcreTable of Contents Seed Rate Charts for Turf Drive ContinuedSection 3 Adjustments Kentucky Blue Grass Pounds per AcreSeed Rate Charts for Turf Drive Continued Metric Seed Rate Charts for Turf DriveTable of Contents Section 3 AdjustmentsTable of Contents Metric Seed Rate Charts for Turf Drive ContinuedSection 3 Adjustments Clover - WhiteTable of Contents Metric Seed Rate Charts for Turf Drive ContinuedSection 3 Adjustments Rye GrassSmall Grass Seeds Attachment Optional Calibrating & Adjusting Seeding RateSeed Rate Speed Change Table of ContentsTable of Contents Small Grass Seeds Attachment Seed RatesSection 3 Adjustments Bird’s-footTrefoil Pounds per AcreTable of Contents Small Grass Seeds Attachment Seed Rates ContinuedSection 3 Adjustments Fescue K-31Section 3 Adjustments Small Grass Seeds Attachment Metric Seed RatesTable of Contents Section 3 Adjustments Table of ContentsFescue K-31 Kilograms per HectareHeight Adjustment Calibrating and Adjusting Seed RateCoil Tines Optional Danish Tines OptionalAdjustment w/o Small Grass Seeds Attach Adjustment w/ Small Grass Seeds AttachWalkboard Optional Table of ContentsSection 4: Maintenance and Lubrication MaintenanceStorage LubricationSeasonally HoursWheel Arm Pivot Shafts Wheel BearingsSmall Grass Seeds Attachment Drive Sprocket Hanger BearingAgitator Lockout Agitator Attachment Table of Contents“Section 3 Adjustments” on page “Important Safety Information” on page“Section 4 Maintenance and Lubrication” on page • “Section 3: Adjustments” on pageWalkboard 313-130A Danish Tine Track Removers 313-077ATable of Contents •“Section 3: Adjustments” on pagePS25 Series Primary Seeder Section 6 Speciﬁcations & Capacities15 Bushel Seeders 30 Bushel SeedersPull-Typewith End Wheels 15 Bushel and 30 Bushel SeedersPull-Typewith Front Wheels Table of ContentsFeatures Section 7 Features & BeneﬁtsBenefits Table of ContentsProblem Section 8: TroubleshootingSolution Uneven seed spacing or uneven standTire Inflation Chart Torque Values ChartSection 9: Appendix Tire SizeWarranty Corporate Ofﬁce P.O. Box