Manuals / Lopi / Household Appliance / Indoor Fireplace

Lopi manual Save these instructions, Pioneer Bay Pellet Insert, Fireplace Mobile Home Approved

Models: Masonry Fireplace Factory Built (Metal) Fireplace Mobile Home Model: Pioneer Bay (Heritage Bay PI)

1 38

Download 38 pages 13.05 Kb

Page 1

Image 1

• Masonry Fireplace

• Factory Built (Metal)

Fireplace

• Mobile Home Approved

Tested and Listed by

Omni-Test Laboratories, Inc.

Beaverton, Oregon

ASTME-1509 1995, ULCC 1482

Pioneer Bay Pellet Insert

-- Please read this entire manual before installation and use of this pellet fuel-burning room heater. Failure to follow these instructions could result in property damage bodily injury or even death.

-- Contact local building or fire officials about restrictions and installation inspection requirements in your area.

-- Save these instructions

Installer: After installation give this manual to the home-

	owner and explain operation of this stove.
$10.00	 Copyright 200 7, T.I.	Part # 93508051
	4051012

4800 Harbour Pointe Blvd. SW

Mukilteo, WA 98275

Page 1

Image 1

Lopi Masonry Fireplace Factory Built (Metal) Fireplace Mobile Home Model: Pioneer Bay (Heritage Bay PI) manual

Contents

Pioneer Bay Pellet Insert Save these instructions• Masonry Fireplace • Factory Built Metal Fireplace Mobile Home ApprovedPage Introduction Introduction1Important Information ModelTravis Industries 2Safety Precautions4 0 5 1 2 1 9 3 5 0 8 0 5Mobile Home Safety PrecautionsTravis Industries 4 0 5 1 2 1Safety Precautions Table of ContentsSpecifications InstallationHeating Specifications SpecificationsDimensions Electrical SpecificationsInstallation Options 6InstallationPlanning The Installation Before You BeginClearances Installation7Mantel Requirements Hearth RequirementsInstalling the Pellet Vent 8InstallationVenting the Pellet Stove Maximum Venting DistanceMobile Home Requirements Installation9Outside Air used for combustion WARNING: DO NOT INSTALL IN SLEEPING ROOMRestrictor Adjustment 1 0InstallationNot Enough Air Too Much AirSurround Panel & Circuit Board Installation Installation1Travis Industries 4 0 5 1 2 1Installation into a Masonry Fireplace 1 2InstallationTravis Industries 4 0 5 1 2 14 0 7 0 2 0 Installation into a Factory Built Metal FireplaceInstallation1 Travis Industries1 4Operation Safety NoticeLocation of Controls Starting the Heater for the First TimeOperation1 Switching Modes While in OperationLoading Pellets The Two Modes of Operation1 6Operation To Adjust the HeatManual Mode To StartAuto Mode To Adjust Room Temperature or Start the StoveHINT To Adjust the Heat1 8Operation Adjusting the Fan SpeedRestrictor Adjustment Not Enough AirPower Outages FAULT LightFault Codes for qualified service personnel only Start-UpSequenceDaily Maintenance whenever using the heater 2 0MaintenanceInspect the Burn Make Sure Pellets are Not Piling UpCleaning the Firepot Maintenance2Check Firepot for Clinkers Travis IndustriesBi-WeeklyMaintenance or every 10 bags of pellets 2 2MaintenanceClean the Heat Exchange Tubes Vacuum HopperMaintenance2 Opening The DoorTravis Industries 4 0 5 1 2 1Clean the Glass 2 4MaintenanceCheck Ashbox, Ashpan, Dispose Ash If Necessary Travis IndustriesMaintenance2 Sweep Ash Into AshpanTravis Industries 4 0 5 1 2 1Yearly Maintenance or every two tons 2 6MaintenanceTravis Industries 4 0 5 1 2 1Maintenance2 Yearly Maintenance or every two tons - ContinuedTravis Industries 4 0 5 1 2 1Yearly Maintenance or every two tons - Continued 2 8MaintenanceTravis Industries 4 0 5 1 2 1Replacement Parts List MaintenanceTravis Industries 4 0 5 1 2 1Exhaust Blower 3 0Normal Operating SoundsHeat Exchanger Tubes FirepotINSERT CLEARANCE DIAGRAM Safety LabelTravis Industries 4 0 5 1 2 1IF WARRANTY SERVICE IS NEEDED 3 2 Limited 7 Year WarrantyTravis Industries 4 0 5 1 2 1Gold Grill Part # Optional EquipmentTravis Industries 4 0 5 1 2 1Thermostat Part # 3 4Optional EquipmentTravis Industries 4 0 5 1 2 1Optional Gold Door part # Optional Log Part #4 0 6 0 2 Optional Equipment4 0 2 0 2 0 3 6IndexTravis Industries 9 3 5 0 8 0 5