Lopi Revere Maintaining Your Appliance, Door Parts, Travis Industries, 100-01165, 4040806

24 Maintaining Your Appliance

Door Parts

7 1

8

14	12
	13
1/8” Hex Wrench	# 20 Torx Driver

NOTE: Place the glass gasket around the perimeter of the door retainer.

NOTE: Glue the door gasket to the door retainer.

2

3

4

5

6

9 10

11

9/16" Wrench

ID #	Description	Qty	Part #	ID #	Description	Qty	Part #
1	Door Shell - Black	1	230-00570	2	Glass (15-3/8" x 8-7/8")	1	173-01002
	Door Shell - Brass		230-00572
	Door Shell - Pewter		230-00568
3	Glass Gasket	1	224-11086	4	Door Retainer (w gasket)	1	224-23020
5	Gasket Cement	1	99900409	6	Door Gasket	1	99900407
7	Door Handle Asbly - Black	1	224-14042	8	Spring - Black	1	100-14122
	Door Handle Asbly - Brass		99900410		Spring - Brass		99300100
	Door Handle Asbly - Pewter		224-14052		Spring - Pewter		100-04103
9	Washers	2	100-03501	10	Cam	1	99900417
11	Nut, Brass	1	101-00007	12	Glass Clips - Top	2	224-230022
					Glass Clip - Bottom	1	224-230021
13	#8-32 3/8" Type F Screw	8	225-20039	14	Set Screw	2	225-20038

Replacing the Glass

The glass must not contact the door retainer or glass clips directly. The glass gasket and glass clip gaskets insulate the glass to prevent cracking. Do not over-tighten the glass clips.

See "Door Shell Installation" (pg. 29) for details on removing the door handle and shell. NOTE: The glass gasket is placed in the grove along the inside perimeter of the door retainer. Make sure the glass clip screws are all fully tightened - they must be flush with the door retainer for the door shell to install.

Replacing the Door Gasket

The door gasket inserts into the outer groove of the door retainer. Stove gasket cement holds it in place. Before installing, remove any residual cement. Lay the gasket in place (start at the lower left corner) and cut off any excess gasket (do not stretch the gasket. The cement fully cures with heat from the stove.

You may need to open and close the door repeatedly to get the gasket to seat fully.

Replacing the Door Handle

See the illustration above for a component list (see pg. 24 for details on adjusting the door).

© Travis Industries 100-01165 4040806