Dipstick | Multiquip EHTX44Y5 guide

		TROUBLESHOOTING


		Troubleshooting (engine) - continued
	Symptom	possible problem	Solution

	Low engine power output and low speed,	Air fi lter blocked?	Clean or replace air fi lter.

		Incorrect valve clearances?	Adjust valves per engine specifi cation.
	black exhaust smoke.	Incorrect valve clearances?	Adjust valves per engine specifi cation.

		Malfunction at injector?	See engine manual.
		Malfunction at injector?	See engine manual.

		Too much oil in engine crankcase?	Drain off engine oil down to uppermark on
		Too much oil in engine crankcase?	dipstick.
			dipstick.

		Entire cooling air system contaminated/	Clean cooling air system and cooling fi n
		blocked?	areas.
	Engine overheats.	Fan belt broken or elongated?	Change belt or adjust belt tension.
	Engine overheats.	Coolant insuffi cient?	Replenish coolant.
		Coolant insuffi cient?	Replenish coolant.
		Radiator net or radiator fi n clogged with dust?	Clean net or fi n carefully.
		Fan, radiator, or radiator cap defective?	Replace defective part.
		Thermostat defective?	Check thermostat and replace if necessary.
		Head gasket defective or water leakage?	Replace parts.

ehtx44y5 RIDE-ON TROWEL • operation manual — rev. #0 (01/16/13) — page 49

Image 49

Multiquip EHTX44Y5 operation manual Dipstick

Contents

Model eHTX44Y5 Fuel and chemical exposure Warnings Respiratory Hazards Silicosis Warning Ehtx Ride-On Trowel Page Completely Training checklist Daily pre-operation checklist Explosive fuel hazards SaFeTy meSSageSBurn hazards Rotating parts hazards GeNeRaL SaFeTy ENgINe SaFeTy TROWeL SaFeTyOrder Form PT-160 Before servicing equipment BaTTeRy SaFeTy FueL SaFeTy„ Use well-insulated gloves when picking up the battery „ NeveR lift trowel with the operator on the machine TRaNSpORTINg SaFeTy„ aLWayS shutdown engine before transporting EmISSIONS INFORmaTION ENvIRONmeNTaL SaFeTy/DeCOmmISSIONINgEmission Control Label Label must remain with the engine for its entire life Ehtx DIMENSIONS/SPECIFICATIONS Guaranteed ISO 112012010 Based SpecificationsGuaranteed ISO 37442010 Based Sound Power Level in dBA b General Information Hour Meter Indicates number of hours machine has been used Controls and Indicators 25 20 Fuel Filter Removes dirt and water from the engine fuel Engine Components Trowel Setup Instructions SetupSeat assembly Battery Setup Hydrauic Oil Level InspectionEngine Oil Level Fuel Operation Insert the ignition key into the ignition switch, FigurePlace the engine speed control lever, in the LOW position Place the engine speed control lever, in the High position Steering Blade Pitch Control Trowel Speed Limiter Control Engine Shut-Down Clean and remove any foreign debris from the trowe MAINTENANCE Remove the air cleaner element Air CleanerOFF position Changing Engine Oil And Filter Checking Engine Oil DailyFilter element from the inside out Gal 9.5 liters Operation in Freezing WeatherVol % Freezing Point Boiling Point Anti 108 226 Fuel Filter Radiator MaintenanceFuel/Water Separator Check and clean battery terminals for corrosion Battery/Charging SystemOil And Fuel Lines Checking The V-Belt Checking/Adjusting Trowel Speed Right Side Trowel Speed AdjustmentLeft Side Trowel Speed Adjustment Engine Tune-Up Blade Pitch Adjustment Bolt Blade Pitch Adjustment Procedure Changing Blades Stabilizer Ring Removal Spider Removal Trowel Arm AdjustmentPlace the trowel on a FLAT, Level surface Remove spider to hydraulic motor retainingscrew Trowel Arm RemovalRemove the trowel arm from the spider plate Checking Trowel Arm Straightness Locate the trowel arm adjustment tool P/N Trowel Arm Adjustment Fixture Components Re-Assembly Checking Hydraulic Steering Pressure Installing Pans Onto Finisher BladesLifting/Crush Hazard. do not lift trowel with pans attached Hydraulic Pump Pressure Test Ports Checking Steering Pressure Steering Pressure AdjustmentCool Oil1 155-175 PSI Hot Oil 145-165 PSI Press the left pitch rocker switch downward Pitch Pressure Out of SpecificationPitch Pressure Check Pitch Pressure Adjustment Pitch Pressure Adjustment SWITCH,KEY Wiring Diagram Hydraulic Diagram Troubleshooting Ride-On Hydraulic Trowel Troubleshooting Wiring? Troubleshooting engine Dipstick HERE’S HOW to GET Help