Safety Notice

BUCK STOVE

“MEETS PHASE II EPA STANDARDS”

MODEL 80 HEATER

FEATURES

PREPARATION INSTALLATION

OPERATION MAINTENANCE SAFETY

If this heater is not properly installed, a house fire may result. For your safety, follow the installation directions. Contact local building or fire officials about restrictions and installation requirements in your area.

Manufactured by New Buck Corp.—Spruce Pine, NC 28777—	Revised 2/03
	PN-PI-8000660
Tested by ITS

Page 1

Image 1

New Buck Corporation Heater Model 80 manual Features Preparation Installation, Operation Maintenance Safety, Safety Notice

Contents

OPERATION MAINTENANCE SAFETY FEATURES PREPARATION INSTALLATIONSAFETY NOTICE “MEETS PHASE II EPA STANDARDS”Page SECTION TABLE OF CONTENTSSECTION SECTIONPage SECTION ROOM HEATER FEATURES Model 80 Wood Stove EPA COMPLIANCE STATUS CATALYST WARRANTYCATALYST EQUIPPED PROPER FUEL SELECTION CATALYST MONITORING ACHIEVING CATALYTIC LIGHT-OFFWHEN REFUELINGCAUTION AGAINST OVER-FIRING ASH REMOVAL INSTALLATIONS Fireplace Insert MASONRY INSERT INSTALLATIONREQUIRED FIREPLACE DIMENSIONS INSTALLATION PRECAUTIONS INSTALLATION PREPARATION POSSIBLE TOOLS NEEDED FOR INSTALLATIONPOSITIONING THE HEATER Fireplace MOUNTING THE TRIM PANELS FINAL CHECK INSTALLATION PRECAUTION RESIDENTIAL FREESTANDING ROOM HEATER INSTALLATIONSECTION FLOOR PROTECTION TOOLS FOR INSTALLATIONMODEL Minimum Clearances CHIMNEY Preparing The Stove for InstallationDETERMINING THE CHIMNEY LOCATION Wall Exit Into Metal Tee-Box Wall Exit Into Masonry using single wall pipe Ceiling Exit-CloseClearance FINAL CHECK ALTERNATIVES FOR WALL PROTECTIONTested and Listed Wall Protector Unlisted and Untested Wall Protector 3.Open the primary air drafts and damper bypass SECTION WOOD HEATER SAFETY OPERATION GUIDE TO THE DIFFERENT BURNING QUALITIES OF WOODSECTION Building a Fire GASKET REPLACEMENT Cold Heater Disassembly Inspection and Catalytic ReplacementPREVENTIVE MAINTENANCE / PARTS REPLACEMENT SECTIONPage Problem TROUBLESHOOTINGSolution SECTION Solution ProblemCOMBUSTOR-RELATEDPROBLEMS Possible Cause NEW BUCK CORPORATION NBC

New Buck Corporation Heater Model 80 manual Features Preparation Installation, Safety Notice

Models: Heater Model 80

BUCK STOVE

“MEETS PHASE II EPA STANDARDS”

MODEL 80 HEATER

FEATURES

OPERATION MAINTENANCE SAFETY

SAFETY NOTICE