Installation Precaution

SECTION III

RESIDENTIAL FREESTANDING ROOM HEATER

INSTALLATION

Extensive field and laboratory testing has shown that catalytic stoves perform best as freestanding stoves when vented into a masonry chimney that include the following:

1.A rain cap is installed on the chimney.

2.Height of chimney is at least 15 feet high.

3.Location of chimney is interior (not on an outside wall).

Satisfactory results have been reported with installations other than listed above. However, draft problems are possible if a hot chimney is not maintained.

Use pedestal kit as follows:

Model 80 #4171B

CAUTION: Do not connect this unit to a chimney flue serving another appliance.

Page 13

Image 13

New Buck Corporation Heater Model 80 Residential Freestanding Room Heater Installation, Installation Precaution, Section

Contents

OPERATION MAINTENANCE SAFETY FEATURES PREPARATION INSTALLATIONSAFETY NOTICE “MEETS PHASE II EPA STANDARDS”Page SECTION TABLE OF CONTENTSSECTION SECTIONPage SECTION ROOM HEATER FEATURES Model 80 Wood Stove EPA COMPLIANCE STATUS CATALYST WARRANTYCATALYST EQUIPPED PROPER FUEL SELECTION CATALYST MONITORING ACHIEVING CATALYTIC LIGHT-OFFWHEN REFUELINGCAUTION AGAINST OVER-FIRING ASH REMOVAL INSTALLATIONS Fireplace Insert MASONRY INSERT INSTALLATIONREQUIRED FIREPLACE DIMENSIONS INSTALLATION PRECAUTIONS INSTALLATION PREPARATION POSSIBLE TOOLS NEEDED FOR INSTALLATIONPOSITIONING THE HEATER Fireplace MOUNTING THE TRIM PANELS FINAL CHECK INSTALLATION PRECAUTION RESIDENTIAL FREESTANDING ROOM HEATER INSTALLATIONSECTION FLOOR PROTECTION TOOLS FOR INSTALLATIONMODEL Minimum Clearances CHIMNEY Preparing The Stove for InstallationDETERMINING THE CHIMNEY LOCATION Wall Exit Into Metal Tee-Box Wall Exit Into Masonry using single wall pipe Ceiling Exit-CloseClearance FINAL CHECK ALTERNATIVES FOR WALL PROTECTIONTested and Listed Wall Protector Unlisted and Untested Wall Protector 3.Open the primary air drafts and damper bypass SECTION WOOD HEATER SAFETY OPERATION GUIDE TO THE DIFFERENT BURNING QUALITIES OF WOODSECTION Building a Fire GASKET REPLACEMENT Cold Heater Disassembly Inspection and Catalytic ReplacementPREVENTIVE MAINTENANCE / PARTS REPLACEMENT SECTIONPage Problem TROUBLESHOOTINGSolution SECTION Solution ProblemCOMBUSTOR-RELATEDPROBLEMS Possible Cause NEW BUCK CORPORATION NBC

New Buck Corporation Heater Model 80 Residential Freestanding Room Heater Installation, Section

Models: Heater Model 80

RESIDENTIAL FREESTANDING ROOM HEATER

INSTALLATION PRECAUTION