Manuals / Regency / Household Appliance / Indoor Fireplace

Regency U32-NG4, U32-LP4 installation manual

Models: U32-NG4 U32-LP4

1 40

Download 40 pages 28.31 Kb

Page 25

Image 25

INSTALLATION

For PROPANE Units and Units Equipped with DC Spark Boxes*

*For installation of the DC Spark Box refer to the LP Conversion instructions in this manual.

U32-4 FPI Direct Vent Gas Insert

Page 25

Image 25

Regency U32-NG4, U32-LP4 installation manual

Contents

U32 Gas Insert Installation ManualOwners TO THE NEW OWNER FPI GAS INSERTSAFETY LABEL TABLE OF CONTENTSINSTALLATION PARTS LISTSAFETY LABEL MA Code - CO Detector REQUIREMENTSfor the State of Massachusetts only 5.08 Modifications to NFPA-54,ChapterSPECIFICATIONS FOR YOUR SAFETYGAS PRESSURE TESTING General Safety InformationMINIMUM FIREPLACE DIMENSIONS INSTALLATION CHECKLISTMasonry and Factory Built Fireplace Installation DiagramDiagram FLUE LINER INSTALLATIONVENTING GAS CONNECTIONAeration Adjustment Wire GAS PIPE PRESSURE TESTINGDiagram DiagramThe 02 refer numbers i.e. 02-43are LOG SET INSTALLATIONmolded into the rear of each log A02-43Rear View Faceplate Assembly Diagram REGENCY FACEPLATE &TRIM INSTALLATIONRear View Trim Assembly Diagram DiagramDiagram DiagramDiagram Diagram 1a Diagram 1bOPTIONAL BAY DOOR BAY LOUVERSOPTIONAL BAY TRIM Removing Bay DoorRemove the 2 screws, push Burner Assembly Installation of LPG Conversion KitCONVERSION KIT #514-969FROM NG TO LP IF IN DOUBT DO NOT DO THIS CONVERSIONIgnitor Wire Piezo Ignitor Installation of the DC SparkerDC Sparker Ignitor Wire Do not over tighten the screw. Recommended toBattery Compartment Ground wire from kitFor P36D-1 / P36-4Only For U32-4OnlyInside ﬂ ange of Side Trim goes over FULL SCREEN DOORSthe inner side of the unit ﬂ ange Push in Corners Bottom Trim BracketScreen Door Hinge Location Bottom Frame HingeTop Frame Switch Box Assembly Boss on rear left side piece HAMPTON CAST FACEPLATE INSTALLATIONEnsure that the top and sides are aligned Bracket inside top of ﬁ rebox Bracket Top Grill HAMPTON CAST GRILL INSTALLATIONSlide side ﬁ ller bracket U31 ONLYKensington Front THE KENSINGTON FRONT INSTALLATIONLeft Side ScrewsShownGlass Door Sub-Frame Sub-Frame Hook THE KENSINGTON 2-PANELDOOR INSTALLATIONLeft Side Door SpacerOPTIONAL REMOTE CONTROL THE KENSINGTON 3-panelDoor InstallationThermostat Wire Table thermostat wires to the 120V wiresCAUTION Label all wires prior WIRING DIAGRAMSto disconnection when servicing controls. Wiring errors can causePage SHUTDOWN PROCEDURE LIGHTING PROCEDURENOT ATTEMPT TO CLEAN THE GLASS WHILE IT IS HOT OPERATING INSTRUCTIONSCOPY OF LIGHTING INSTRUCTION PLATE MAINTENANCE INSTRUCTIONSDO NOT REMOVE THIS INSTRUCTION PLATE LOG REPLACEMENT GENERAL VENT MAINTENANCEFlush Glass Replacement GOLD-PLATEDTRIMDisconnect green wire from power cord FAN MAINTENANCEBay Glass Removal TO REMOVE FANINSTALLING VALVE VALVE REPLACEMENTthe entrire assembly out 1Shut off the gas supplyMAIN ASSEMBLY PARTS LISTDescription DescriptionBURNER ASSEMBLY & LOG SET Description BAY & FLUSH FRONT ASSEMBLYBay Door Flush DoorDescription FACEPLATE ASSEMBLY402-919 Complete Faceplate Set Contour187 189 188 194 203 HAMPTON CAST - FACEPLATE ASSEMBLYPage Page Page The Warranty Limited Lifetime WARRANTYConditions ExclusionsSee the inside back cover for details