25
Yes
FLAME FAILURE FUNCTIONAL CHECK 3
PILOT WILL NOT STAY LIT OR FIRE GOES OUT IN USE
If the appliance goes out in use continually, this may mean that the oxygen
depletion sensor has been activated. The appliance should not be used until the
cause has been found and rectified.
Ensure there is no debris around the pilot assembly,
(e.g. coal, soot etc.) Check for fluff in the pilot aeration hole.
See diagram 13 arrow A in replacing parts section.
Light the pilot and keep the control knob pushed in | ||||
| at least 10 seconds before letting go. |
| ||
| No | Yes |
| |
With the pilot | Will pilot |
|
| |
stay alight? |
| With the fire running | ||
running is the gas |
| |||
|
| on full is the gas at | ||
pressure as stated on |
|
| ||
No | No | the pressure stated | ||
the databadge? | ||||
on the databadge? | ||||
| Problem is with the |
| ||
|
|
| ||
| pipework or |
|
| |
| fittings which lead |
| Yes | |
| to the fire. Correct |
| ||
| and retry. |
|
| |
| Yes |
|
|
|
|
|
|
|
|
|
|
|
|
|
| Run for 3 mins, | Yes | ||
|
|
|
|
|
|
|
|
|
|
|
|
|
| ||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| ||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| turn off, time interval | ||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| until mag unit shuts | ||
|
|
|
|
|
|
|
|
|
|
|
|
| No |
| with a click. Is this | ||||
Is the pilot flame of the |
|
|
|
|
|
|
|
|
|
|
| greater than 7 | |||||||
|
|
|
| Is thermocouple |
|
|
|
|
|
| seconds? | ||||||||
correct length? See |
|
|
|
|
|
|
|
|
|
| |||||||||
|
|
|
| connection good |
|
|
|
|
|
|
|
|
| ||||||
diagram 13 in replacing |
|
|
|
|
|
|
|
|
|
|
|
| |||||||
parts section. |
|
|
|
| in back of valve? |
|
|
|
|
|
|
| No | ||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| |||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| Yes |
|
|
|
|
|
|
|
|
| Tighten the |
| |||
| No |
|
|
|
|
|
|
|
|
|
|
|
|
| connection and retry. |
| |||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| |||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| ||
|
|
|
| Replace ODS unit. |
|
|
|
|
|
|
| ||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| |
|
|
|
|
|
|
|
|
| Yes |
|
| Run for 3 mins, turn |
| ||||||
|
|
|
|
|
|
|
|
|
|
|
| ||||||||
|
|
|
|
|
|
| Will pilot |
|
| ||||||||||
|
|
|
|
|
|
|
|
|
| ||||||||||
Change the |
|
|
|
|
| stay alight? |
|
|
|
|
|
|
| off, time interval until |
| ||||
|
|
|
|
|
|
|
|
|
|
|
| mag unit shuts with a |
| ||||||
ODS unit. |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| ||||
|
|
|
|
|
| No |
|
| No |
|
| click. Is this greater |
| ||||||
|
|
|
|
|
|
|
|
|
|
|
|
| |||||||
|
|
|
|
|
|
|
|
|
|
|
|
| than 7 seconds? |
| |||||
|
|
|
|
|
| Change mag |
|
|
|
|
|
|
|
|
|
|
| ||
|
|
|
|
|
|
| unit. |
|
|
|
|
|
|
|
|
| Yes | ||
SYSTEM OK
FAULT FINDING CHARTS | SERVICING INSTRUCTIONS |
