Turbo Chef Technologies Tornado 2 owner manual Example 2 French Fries & Frozen Puff Dough Items

22 rec i pe development and cooking tips

Finish:

Little to no microwave is used. The air is moderate to high to finish the caramelization of the product, and achieve the desired color.

A recipe might look like this:

S tep	Ev en t	% Ti me	% A I R	% Wav
Defrost	1	30	10	100
Cook	2	40	50	90
Finish	3	30	60	30
	4	0	10	0
	5	0	10	0
	6	0	10	0

Example 2: French Fries & Frozen Puff Dough Items

Just like with a frozen pizza, these two items will have to be defrosted, cooked and then finished.

However while French fries and frozen puff dough items must go through the same stages of cooking, the specifics of these stages will differ based on the specific properties of the items being cooked.

A recipe for French fries might look like this:

S tep	Ev en t	% Ti me	% A I R	% Wav
Defrost	1	80	100	80
Cook	2	10	100	90
Finish	3	10	100	0
	4	0	10	0
	5	0	10	0
	6	0	10	0

For frozen puff dough, the recipe could be:

S tep	Ev en t	% Ti me	% A I R	% Wav
Defrost	1	20	20	90
Cook	2	50	60	20
Finish	3	10	40	0
	4	20	80	0
	5	0	10	0
	6	0	10	0

Note that for the frozen puff dough, a rest was added between the cooking and finishing steps. This allows the product to achieve its full-layered effect.

The Importance of Consistency

Speed cook ovens leave little room for error and a slight change in the product’s weight or starting state can have major effects on the final outcome. Because of this, product consistency is extremely important in developing and using recipes.

When developing and using recipes, a consistent outcome will depend on keeping the following variables constant.

oPortion and/or weight

oBeginning temperature and state

The same product cooked from frozen and fresh will have two very different recipes.

oCooking vessel

Different materials react with the technology in different ways. For a list of suggested cooking materials for use with the Tornado oven, see the Ovenables section on the following page.

oThe oven’s state

It is recommended that the oven be on for at least 30 minutes prior to developing recipes.

Don’t be Afraid to Experiment

In developing recipes, don’t be afraid to experiment. Write down current settings and then start testing variations. Old recipes can always be re-programmed into the oven in a matter of seconds.

Note: After entering or editing a recipe, it is best to back out of the Edit Mode and run the Recipe in the On Mode.

Note: C3 and Tornado recipes and cook settings are not interchangeable.