Hearth and Home Technologies CASTLEWOOD 42 owner manual Non-combustible Sealant

Page 24

E. Non-combustible Sealant

After completing the framing and applying the facing ma- terials over the framing, a bead of 300° F minimum non- combustible sealant or motar must be used to close off any gaps at the top and sides between the fireplace and hearth.

Non-combustible Sealant

Figure 12.6 Place Non-combustible Sealant

Flush Hearth Extension Framing

•Fireplace must be recessed 3 3/4 in. (95.3 mm) below the finished floor.

24	Outdoor Lifestyles by Hearth & Home Technologies Inc. • 4070-300 Rev C • 4/11

Image 24

Contents

Hot glass will cause burns Fire RiskListing Label Information/Location GrateNumber Table of Contents Listing and Code Approvals Appliance CertificationNot intended for use as a primary heat source Do not overfireGetting Started Inspect Fireplace and Components GrateFirescreen Cooling AirFreestanding Installations see Figure Framing and ClearancesSelecting Fireplace Location Exterior Walls see FigureFreestanding Installation Clearances Sidewalls/Surrounds Frame the FireplaceChimney Requirements Installation of Fireplace Secure the Fireplace Position the FireplaceLevel the Fireplace Place the Protective Metal Hearth StripsInstall Cooling Air Hoods Chimney Assembly Height of Chimney ComponentsAssemble the Chimney Sections Using Offsets/Returns Install the Termination Cap Complete the EnclosureChase Top ST1175/ST475 Square Termination CapInstalling a TCT1175 Square Termination Cap TCT1175 Terra Cotta CapInstallation of Molded Brick Panel Install Side Molded Brick Panel Install Screens Mortar Optional GrateAccessories Gas Log/Lighter ProvisionsGas Code, Ansi Z223.1 Asphyxiation RiskFinishing Hearth Extension= 1/k x inches of thickness Raised Hearth Extension Framing Non-combustibleFraming Material Equivalent insulationNon-combustible Sealant Flush Hearth Extension FramingFinishing Material Use only non-combustible framing material below standoffsMantel StandoffsOperating Instructions General InformationClear Space Near the Fireplace Glass DoorsFire Risk Smoke Risk Wood Fuel FirewoodStarting a Fire Troubleshooting Diagnostics and Problem SolvingMaintenance and Servicing the Fireplace Disposal of Ashes Chimney Inspection/CleaningMaintenance Task List When cleaning glass doorClean Chimney FireFireplace Dimensions Reference MaterialsOptional Components Chimney Components Catalog #330 mm 51 mm Termination caps 15-3/4 400 mmService Parts List ODCASTLEWD-42At Depot Traditional Molded Brick PanelHerringbone Molded Brick Panel Warranty Coverage Limited Warranty This warranty is void ifRO N a CO ISD D