Char-Broil 463257010 manual Grill head Regulator hose

Page 18

3

Place lower back panel between side panels at rear of bottom shelf. Secure lower back panel to side panels using two 1/4-20x1/2”screws, 7mm lock washers, and 7mm flat washers on each side.

Lower back panel 1/4-20x1/2” screw

7mm lock washer 7mm flat washer

4

This step requires two people to lift and position grill head onto cart. Carefully lower the grill head onto the cart, aligning slots at bottom of grill head with posts on cart side panels. Make sure the regulator hose is hanging outside the cart. Grill head must face open side of cart.

Grill head

Regulator hose

18

Image 18

Contents Estimated assembly time 30 minutes Date PurchasedTable of Contents This Grill is for Outdoor USE onlyInstallation Safety Precautions California PropositionFirst Time Use TemperatureGrilling Guide Getting Started Lava Rock / BriquettesDirect Cooking Food SafetyGrilling Guide Grilling Indirect CookingUsda Recommended Safe Minimum Internal Temperatures Grilling Guide Tips & TricksGrilling Guide Cleaning Your Grill LP Cylinder Filling USE and CareLP Liquefied Petroleum Gas UL listed Overfill ProtectionFor your safety UseDo not household cleaning agents. Damage to gasLP Cylinder Leak Test Leak Testing Valves, Hose and Regulator Connection, do not use this regulatorTurn all grill control knobs to OFF SDo not lean over grill while lighting For Safe Use of Your Grill and to Avoid Serious InjuryIgnitor Lighting Open lid during lightingSideburner Match Lighting General Grill CleaningSideburner Ignitor Lighting Burner Flame CheckVery Important Burner tubes must reengage valve Cleaning the Burner AssemblyStoring Your Grill Turn gas OFF at control knobs and LP cylinderLimited Warranty All Other Parts Year from date of purchaseParts List Not PicturedParts Diagram Rear AssemblyFront 20x1/2 screws, 7mm lock washers,Grill head Regulator hose Upper back panel Holes on fascia to Attach valve bracket Holes on fascia to Attach bezelFully tighten lower screws on upper back panel Sideburner valve, shown C Self-tapping screw Wire Heat shieldClarity of illustration Cylinder screw at rear of cart AA Battery Electronic Ignition Cap Troubleshooting Emergencies Possible Cause Prevention/SolutionAUTO-CLEAN Troubleshooting Electronic Ignition SectionPage Warranty Registration Department Box Columbus, GA