Char-Broil 463257010 manual California Proposition, Installation Safety Precautions

Page 3

WARNING

CALIFORNIA PROPOSITION 65

1.Combustion by-products produced when using this product contain chemicals known to the State of California to cause cancer, birth defects, and other reproductive harm.

2.This product contains chemicals, including lead and lead compounds, known to the State of California to cause cancer, birth defects or other reproductive harm.

Wash your hands after handling this product.

Installation Safety Precautions

•Use grill, as purchased, only with LP (propane) gas and the regulator/valve assembly supplied. A conversion kit for dual fuel grills must be purchased for use with natural gas.

•Grill installation must conform with local codes, or in their absence of local codes, with either the National Fuel Gas Code, ANSI Z223.1/ NFPA 54, Natural Gas and Propane Installation Code, CSA B149.1, or Propane Storage and Handling Code, B149.2, or the Standard for Recreational Vehicles, ANSI A 119.2/NFPA 1192, and CSA Z240 RV Series, Recreational Vehicle Code, as applicable.

•All electrical accessories (such as rotisserie) must be electrically grounded in accordance with local codes, or National Electrical Code, ANSI / NFPA 70 or Canadian Electrical Code, CSA C22.1. Keep any electrical cords and/or fuel supply hoses away from any hot surfaces.

•This grill is safety certified for use in the United States and/or Canada only. Do not modify for use in any other location. Modification will result in a safety hazard.

WARNING

CAUTION

Using pots larger than 6 quarts in capacity could exceed weight limit of the

side burner shelf or side shelf, resulting in failure of grill cart components.

Do not attempt to repair or alter the hose/valve/regulator for any “assumed” defect. Any modification to this assembly will void your warranty and create the risk of a gas leak and fire. Use only authorized replacement parts supplied by manufacturer.

3

Page 2 Page 4
Image 3
Page 2 Page 4
Contents Date Purchased Estimated assembly time 30 minutesThis Grill is for Outdoor USE only Table of ContentsCalifornia Proposition Installation Safety PrecautionsLava Rock / Briquettes TemperatureGrilling Guide Getting Started First Time UseIndirect Cooking Food SafetyGrilling Guide Grilling Direct CookingGrilling Guide Tips & Tricks Usda Recommended Safe Minimum Internal TemperaturesGrilling Guide Cleaning Your Grill UL listed Overfill Protection USE and CareLP Liquefied Petroleum Gas LP Cylinder FillingFor your safety UseDo not household cleaning agents. Damage to gasLP Cylinder Leak Test Leak Testing Valves, Hose and Regulator Connection, do not use this regulatorTurn all grill control knobs to OFF Open lid during lighting For Safe Use of Your Grill and to Avoid Serious InjuryIgnitor Lighting SDo not lean over grill while lightingBurner Flame Check General Grill CleaningSideburner Ignitor Lighting Sideburner Match LightingTurn gas OFF at control knobs and LP cylinder Cleaning the Burner AssemblyStoring Your Grill Very Important Burner tubes must reengage valveAll Other Parts Year from date of purchase Limited WarrantyNot Pictured Parts ListParts Diagram 20x1/2 screws, 7mm lock washers, AssemblyFront RearGrill head Regulator hose Upper back panel Holes on fascia to Attach valve bracket Holes on fascia to Attach bezelFully tighten lower screws on upper back panel Sideburner valve, shown C Self-tapping screw Heat shield WireClarity of illustration Cylinder screw at rear of cart AA Battery Electronic Ignition Cap Emergencies Possible Cause Prevention/Solution TroubleshootingAUTO-CLEAN Section Troubleshooting Electronic IgnitionPage Warranty Registration Department Box Columbus, GA
Top Page Image Contents