Char-Broil 463257010 manual Cylinder screw at rear of cart

Page 25

17

LP CYLINDER IS SOLD SEPARATELY. Fill and leak check the cylinder before attaching to grill and regulator (see Use & Care section). Once cylinder has been filled and leak checked, place cylinder into hole in bottom shelf. Make sure cylinder valve is facing front of grill. Secure cylinder with cylinder screw under bottom shelf. Insert regulator through large hole in

left side panel. See Use & Care section of this manual to perform the “Burner Flame Check” and for important safety instructions before using.

Cylinder screw at rear of cart

Cylinder screw

LP Cylinder ( not included)

Always keep LP cylinders in upright position during use, transport, and storage.

CAUTION	Regulator

Cylinder valve must face to front of cart once tank is attached. Failure to install cylinder correctly may allow gas hose to be damaged in operation, resulting in the risk of fire.

.

18 On back of grill, slide grease tray into opening in upper back panel.

CAUTION

Failure to install grease tray will cause hot grease to drip from bottom of grill with risk of fire or property damage.

Grease tray

25

Image 25

Contents Date Purchased Estimated assembly time 30 minutesThis Grill is for Outdoor USE only Table of ContentsCalifornia Proposition Installation Safety PrecautionsGrilling Guide Getting Started TemperatureFirst Time Use Lava Rock / BriquettesGrilling Guide Grilling Food SafetyDirect Cooking Indirect CookingGrilling Guide Tips & Tricks Usda Recommended Safe Minimum Internal TemperaturesGrilling Guide Cleaning Your Grill LP Liquefied Petroleum Gas USE and CareLP Cylinder Filling UL listed Overfill ProtectionUseDo not household cleaning agents. Damage to gas For your safetyLP Cylinder Leak Test Connection, do not use this regulator Leak Testing Valves, Hose and RegulatorTurn all grill control knobs to OFF Ignitor Lighting For Safe Use of Your Grill and to Avoid Serious InjurySDo not lean over grill while lighting Open lid during lightingSideburner Ignitor Lighting General Grill CleaningSideburner Match Lighting Burner Flame CheckStoring Your Grill Cleaning the Burner AssemblyVery Important Burner tubes must reengage valve Turn gas OFF at control knobs and LP cylinderAll Other Parts Year from date of purchase Limited WarrantyNot Pictured Parts ListParts Diagram Front AssemblyRear 20x1/2 screws, 7mm lock washers,Grill head Regulator hose Upper back panel Holes on fascia to Attach bezel Holes on fascia to Attach valve bracketFully tighten lower screws on upper back panel Sideburner valve, shown C Self-tapping screw Heat shield WireClarity of illustration Cylinder screw at rear of cart AA Battery Electronic Ignition Cap Emergencies Possible Cause Prevention/Solution TroubleshootingAUTO-CLEAN Section Troubleshooting Electronic IgnitionPage Warranty Registration Department Box Columbus, GA