Char-Broil 463257010 manual Sideburner valve, shown C

Page 21

		Insert sideburner burner into left shelf.The stud on bottom of burner fits into rear small hole in sideburner drip pan on
	9
	9	shelf, shown A. Secure burner to sideburner drip pan with one Wing nut, shown B. Make sure burner tube engages
		sideburner valve, shown C.

Sideburner burner

drip pan

Wing nut

Sideburner drip pan

Burner tube

10 Under sideburner shelf, attach sideburner ignitor wire to electrode, shown A. Place sideburner grate onto sideburner shelf, aligning grate legs with holes in shelf, shown B.

Electrode

Sideburner grate

Sideburner Ignitor Wire

Image 21

Contents Date Purchased Estimated assembly time 30 minutesThis Grill is for Outdoor USE only Table of ContentsCalifornia Proposition Installation Safety PrecautionsGrilling Guide Getting Started TemperatureFirst Time Use Lava Rock / BriquettesGrilling Guide Grilling Food SafetyDirect Cooking Indirect CookingGrilling Guide Tips & Tricks Usda Recommended Safe Minimum Internal TemperaturesGrilling Guide Cleaning Your Grill LP Liquefied Petroleum Gas USE and CareLP Cylinder Filling UL listed Overfill ProtectionFor your safety UseDo not household cleaning agents. Damage to gasLP Cylinder Leak Test Leak Testing Valves, Hose and Regulator Connection, do not use this regulatorTurn all grill control knobs to OFF Ignitor Lighting For Safe Use of Your Grill and to Avoid Serious InjurySDo not lean over grill while lighting Open lid during lightingSideburner Ignitor Lighting General Grill CleaningSideburner Match Lighting Burner Flame CheckStoring Your Grill Cleaning the Burner AssemblyVery Important Burner tubes must reengage valve Turn gas OFF at control knobs and LP cylinderAll Other Parts Year from date of purchase Limited WarrantyNot Pictured Parts ListParts Diagram Front AssemblyRear 20x1/2 screws, 7mm lock washers,Grill head Regulator hose Upper back panel Holes on fascia to Attach valve bracket Holes on fascia to Attach bezelFully tighten lower screws on upper back panel Sideburner valve, shown C Self-tapping screw Heat shield WireClarity of illustration Cylinder screw at rear of cart AA Battery Electronic Ignition Cap Emergencies Possible Cause Prevention/Solution TroubleshootingAUTO-CLEAN Section Troubleshooting Electronic IgnitionPage Warranty Registration Department Box Columbus, GA

sideburner valve, shown C.