Coleman 9949A Burner and Orifice, Leak Testing Disposable LP Gas Cylinders, Fixing a Fuel Leak

Page 7

Burner and Orifice

Proper location of the burner with respect to the orifice is important. To verify the proper installation of the venturi tube, use a screwdriver to remove the grill top. The venturi tube must be located over the orifice fitting. See Fig. 26 (grill top not shown).

Fig. 26

Orifice Fitting

Burner

Venturi Tube

Check and clean the burner/venturi tubes for insects and insect nests. A clogged tube can lead to a fire beneath the appliance.

Leak Testing - Disposable LP Gas Cylinders

DANGER

TO PREVENT FIRE OR EXPLOSION HAZARD:

rNO SMOKING. DO NOT use or permit sources of ignition in the area while doing a leak test.

rPerform leak tests outdoors only.

rNEVER perform a leak test with fire or flame.

How to Check for Leaks

1.Make a soapy solution of equal parts mild liquid dishwashing detergent and water.

2.Turn off all burner control knobs.

3.Apply a soap solution to the connections indicated with the arrows. (Fig. 27) If bubbles appear at these areas, a leak is indicated.

No Smoking

No Flame

Fig. 27

Fixing A Fuel Leak

If you detect a leak:

1.Stop a leak by tightening the loose joint, or by replacing the faulty part with a replacement part recommended by Coleman. DO NOT attempt to repair the cylinder if it should become damaged; the cylinder MUST be replaced.

2.If you are unable to stop a leak, remove the cylinder from the grill. DO NOT use the grill until the leak is corrected.

When to test for leaks:

1.Perform a leak test each time the gas supply cylinder is connected to the regulator. Leak test anytime a part of the gas system is replaced.

Start-Up Check List

WARNING

Failure to follow these safety steps before using the grill each time could result in a fire that could be hazardous to you, your appliance or property. It is especially important to observe these steps after the grill has been stored, moved or cleaned.

1.Regularly check the burner venturi tubes for blockage from an insect nest. Read “Cleaning the Venturi” in the section titled “Care, Maintenance, and Cleaning”, and also the section titled “Troubleshooting”.

2.Check that all the burner venturi [A] are set over the valve

outlets [B] correctly. The valve orifice [C] must be inside the venturi. (Fig. 28)

3.Use only the gas specified.

4.Keep the grill on a level surface.

5.Keep the grease pan empty at start up.

B CA

Fig. 28

REPRESENTATIVE ILLUSTRATION

CAUTION

DO NOT add charcoal or lighting fluid!

English-7

Image 7
Contents Use, Care & Assembly Manual Technical Characteristics ContentsGeneral Safety Information Cylinder Specifications General InstallationPortable L.P. Gas Barbecue Cylinders Grill Features Assemble Wheels and Towing Handle Set up the GrillInstall the Drip Tray Assemble GrillInstalling 1 lb. Propane Cylinder Fixing a Fuel Leak Leak Testing Disposable LP Gas CylindersHow to Check for Leaks Burner and OrificeMatch Lighting Lighting InstructionsLighting The Burners Instastart Electronic IgnitionGeneral Use and Correct Burner Flames Shutting Off the GrillGrilling Tips and Hints Case of Grease Fire Care, Maintenance and CleaningCooking Methods Steps For Cleaning Venturi Cleaning the VenturiSuggested Cleaning Materials Component CleaningMoving and Storage TroubleshootingColeman Grill Registration Card Congratulations on Your NEW Coleman Grill Purchase Replacement Parts List 9949A Series Limited Five Year Warranty WarrantyBarbecue à gaz Caractéristiques techniques Table des matièresGénéralités de sécurité Bouteilles portatives de gaz propane Généralités d’installationNormes applicables aux bouteilles Caractéristiques du gril Mise en place du plateau à graisse Assemblage du grilMontage des roues et de la poignée de traction Mise en place du grilMise en place d’une bouteille de propane de 465 g Élimination des fuites Brûleur et orificeDétection des fuites Bouteilles de propane jetables Détection des fuitesAllumage avec une allumette Instructions d’allumageAllumage des brûleurs Allumage électronique InstastartGénéralités d’emploi et flammes correctes Extinction du grilConseils pratiques de grillage Modes de cuisson En cas de feu de fritureNettoyage, soins et entretien Nettoyage du diffuseur Nettoyage du diffuseurProduits de nettoyage suggérés Nettoyage des élémentsDépannage Déplacement et remisageNomenclature Série 9949A Garantie limitée de cinq ans GarantieManual de Uso, Cuidado Y Ensamblaje Características Técnicas ContenidoInformación General de Seguridad Cilindros para la Barbacoa de Gas L.P. Portátil Instalación GeneralEspecificaciones del Cilindro Caracteristícas de la Parrilla Instale la Bandeja para Goteos Ensamblaje de la ParrillaEnsamble las Ruedas y el Asa para Remolcar Monte la ParrillaEnrosque solamente con la mano. no use herramientas Instale el Cilindro de Propano de 1lb. .45 kgReparando Una Fuga de Combustible Quemador y OrificioComprobación de Fugas Cilindros de Gas LP Desechables Como Verificar por FugasEncendido con Fósforos Instrucciones Para EncenderEncendiendo los Quemadores Encendido Electrónico InstastartUso General y Llamas Correctas en el Quemador Apagando la ParrillaSugerencias y Consejos para Asar Métodos para Cocinar En Caso de un Fuego de GrasaCuidado, Mantenimiento y Limpieza Pasos Para Limpiar El Venturi Limpieza del VenturiMateriales de Limpieza Sugeridos Limpieza de los ComponentesTransporte y Almacenaje Solución de ProblemasLista de Piezas de Reemplazo Series 9949A Garantía Limitada de Cinco Años Garantía

9949A specifications

The Coleman 9949A is an innovative portable propane grill designed for outdoor cooking enthusiasts who seek convenience, versatility, and efficiency while enjoying nature. This compact yet powerful grill is perfect for camping trips, tailgating parties, or backyard cookouts.

One of the main features of the Coleman 9949A is its portable design, which includes a foldable frame that enables effortless transportation and storage. Weighing around 10 pounds, it is lightweight and easy to carry, making it an ideal solution for those who want to grill on the go.

The grill boasts a cooking surface measuring 200 square inches, which provides ample space to grill a variety of foods simultaneously. The cooking grate is coated with a non-stick surface, allowing for easy food release and quick cleanup. Additionally, the grill's height-adjustable design ensures that users can comfortably cook without straining their backs.

Fueling the Coleman 9949A is a standard 16.4-ounce propane cylinder, which is easily attachable and can be replaced without hassle when running low. The grill utilizes a convenient Insta-Start ignition system, enabling quick and reliable starts without the need for matches or lighters. This means less preparation time and more time enjoying delicious grilled meals.

In terms of cooking performance, the Coleman 9949A features a powerful burner that delivers up to 20,000 BTUs of heat. This allows users to achieve the desired temperatures for a wide variety of cooking techniques, such as grilling, searing, and even low-and-slow cooking. The grill’s wind-blocking design helps maintain heat efficiency even in breezy conditions, ensuring consistent cooking results.

User safety and convenience are top priorities for the Coleman 9949A. It is equipped with a pressure regulator that ensures a steady gas flow, preventing flare-ups and optimizing fuel efficiency. The grill's sturdy construction assures durability, so it can withstand the rigors of outdoor use.

With its combination of portability, efficient cooking capability, and user-friendly features, the Coleman 9949A is an excellent choice for anyone looking to enhance their outdoor cooking experience. Whether you’re grilling burgers, veggies, or seafood, this grill is designed to deliver delicious results every time. Enjoying great food in the great outdoors has never been easier!