Weber 54265 manual Check for GAS Leaks, Remove Control Knobs & Control Panel For Leak Testing

Page 11

GAS INSTRUCTIONS

Remove Control Knobs & Control Panel For Leak Testing

1

2

You will need: Phillips screwdriver..

 

 

A) Take off the burner control knobs (1)..

 

 

B) Remove screw and washer from back of control panel with a Phillips screwdriver (2)..

 

 

C)

Remove machine screw from lower left and right side of control panel with a Phillips

 

 

 

screwdriver (3)..

3

 

D)

Tilt the back edge of the control panel up.. Carefully lift control panel up and away

 

 

 

 

from frame (4)..

 

 

E) Disconnect the igniter wires from the ignition module (5)..

 

 

F)

Replace control panel when leak check is completed.. ◆

 

 

4

5

CHECK FOR GAS LEAKS

mDANGER

Do not use an open flame to check for gas leaks. Be sure

 

there are no sparks or open flames in the area while you

1

check for leaks. Sparks or open flames will result in a fire or

explosion, which can cause serious bodily injury or death

 

and damage to property.

 

Note: All factory-made connections have been thoroughly checked for gas leaks.The burners have been flame-tested.As a safety precaution, however, you should recheck all fittings for leaks before using your Weber® gas barbecue. Shipping and handling may loosen or damage a gas fitting.

mWARNING: The gas connections of your gas grill have been factory tested. We do however recommend that you leak check all gas connections before operating your gas grill.

mwarNING: Perform these leak checks even if your barbecue was dealer or store assembled.

If your grill has a side burner, make sure the side burner is turned off..

Turn on gas supply at source..

mWARNING: Do not ignite burners when leak checking.

You will need: A soap and water solution and a rag or brush to apply it..

A)Mix soap and water..

B)Turn on gas supply (1)..

C)Check for leaks by wetting the fitting with the soap and water solution and watching for bubbles.. If bubbles form, or if a bubble grows, there is a leak..

If there is a leak, turn off the gas and tighten the fitting. Turn the gas back on and recheck with the soap and water solution. If leak does not stop, do not use the barbecue. Contact the Customer Service representative in your area using the contact information on our web site. Log onto www.weber.com®.

D)When leak checking is complete, turn gas supply off at the source and rinse connections with water..

Note: Since some leak test solutions, including soap and water, may be slightly corrosive, all connections should be rinsed with water after checking for leaks.

mWARNING: You should check for gas leaks every time you disconnect and reconnect a gas fitting.

www.weber.com® 11

Page 10 Page 12
Image 11
Page 10 Page 12
Contents Gas Grill Liquid Propane GAS Units only Table of Contents Exploded View 210 Diagrama DE Despiece 210 VUE Eclatee Left Frame Panel Thermometer BezelShroud Cubierta Boîtier Handle Asa Poignée Warming Rack CookboxExploded View 310 Diagrama DE Despiece 310 VUE Eclatee Panel izquierdo del bastidor Panneau avant Operating WarrantyGeneral Instructions Storage AND/OR NonuseGas Line Piping Install GAS SupplyGeneral Specifications For Piping GAS InstructionsLeak Check PREPARAtioN What is Natural GAS?Type of GAS Natural GAS ConnectionCheck for GAS Leaks Remove Control Knobs & Control Panel For Leak TestingCheck Reinstall Control PanelHose Inspection Before Using the GrillSLIDE-OUT Grease Tray and Disposable Drip PAN Electronic Igniter InspectionCrossover Ignition System Main Burner Ignition & UsageMain Burner Ignition To ExtinguishApagado Arrete Drippings and Grease Grilling Tips & Helpful HintsPreheating Covered CookingGrease tray with aluminum foil TroubleshootingWeber SPIDER/INSECT Screens MaintenanceCleaning Control Panel Removal Burner Tubes Cleaning or ReplacementBurner Tube Cleaning Burner Tube ReinstallationElectronic Crossover Ignition System OPERatioNS Annual MaintenanceReplace Battery If Necessary Inspection and Cleaning of the Spider/Insect ScreensBarbacoa de Gas Únicamente Unidades DE GAS Propano Licuado AdvertenciasInstrucciones Generales ÍndiceAlmacenaje GarantíaInstrucciones Generales Instalación CanadienseTubería de la Línea de Gas Instrucciones Sobre EL GASInstale EL Suministro DE GAS Especificaciones Generales para la TuberíaPreparativos Para LA Búsqueda DE Fugas Tipo DE GAS¿QUÉ ES EL GAS NAtural? Conexión DEL GAS NAturalDetección DE Fugas DE GAS Vuelva a instalar el panel de control RevisarInspección DEL Encendedor Electrónico Antes DE Utilizar LA BarbacoaBandeja Corrediza RECOLECTORa DE GRAsa Y Bandeja DE Goteo DesechableSistema De Encendido Crossover Encendido Y USO DEL Quemador PrincipalEncendido DEL Quemador Principal Para ApagarEncendido Manual DEL Quemador Principal Pringues Y Grasa Consejos Prácticos Para AsarPRECALENTado Cocción CubiertaDe grasa con hoja de Resolución DE ProblemasPrecaución No forre La bandeja deslizanteLimpieza MantenimientoRevisiones Para Detectar Fugas DE GAS Limpieza O Reemplazo DE LOS Tubos DEL QuemadorPatrón de la Llama del Quemador Operación DEL SISteMA DE Encendido CRossoVERMantenimiento Anual Reemplace La Batería Si Fuese NecesarioGrill a GAZ Appareils a GAZ Propane Uniquement Mises EN GardeInstructions Relatives AU GAZ Table DES MatieresStockage Installation AU CANADaGarantie GeneralitesCanalisation de la conduite de gaz Installer L’ARRIVEE DE GAZInstructions Relatives AU GAZ Spécifications générales de la canalisationPreparation DE LA Detection DES Fuites Type DE GAZQU’ESt-CE QUE LE GAZ NAturel ? Raccordement AU GAZ NAturelDétecter les fuites Detection DES Fuites DE GAZVérifiez Remettez en place le panneau de commandesInspection DU Tuyau Avant D’UTILISER LE GrillInspection DE L’ALLUMEUR Electronique Dispositif D’allumage Crossover Allumage & Utilisation DU Bruleur PrincipalAllumage DU BRuleur Principal Pour EteindreApagado Arrete Ecoulements DE JUS ET DE Graisses Astuces Pour LA GrilladePréchauffage Cuisson CouverteDepannage Nettoyage Nettoyage du tube du brûleur Nettoyage OU Remplacement DES Tubes DU BRuleurRetrait du panneau de commandes Retrait du tube du brûleurAspect des Flammes du Brûleur Maintenance AnnuelleUtilisation DU Dispositif D’ALLUMAGE ELECTRoNIQUE CRossoVER Remplacez La Pile Si NecessaireMemo Memo Memo WEBER-STEPHEN Products LLC

Spirit Natural Gas Grill, 54265 specifications

The Weber 54265 Spirit Natural Gas Grill is a remarkable outdoor cooking appliance designed for both novice and seasoned grill enthusiasts. Combining innovative technology with user-friendly features, it has quickly become a favorite for those who enjoy grilling year-round.

One of the standout features of the Weber 54265 is its efficient cooking system that boasts a generous cooking surface measuring 529 square inches. This expansive area allows users to grill multiple items simultaneously, making it ideal for family gatherings or backyard barbecues. The grill includes a warming rack, ensuring that already-cooked food remains hot while you're finishing up the main course.

The Weber Spirit is equipped with powerful GS4 grilling system, which includes innovative components such as efficient burners, Flavorizer bars, a grease management system, and the Infinity ignition. The GS4 system ensures consistent heat distribution and minimizes flare-ups, providing a safer and more enjoyable grilling experience. The stainless steel burners are built to last and deliver even heat, allowing for precise temperature control.

Durability is a key characteristic of the Weber 54265. Constructed with high-quality materials, including a porcelain-enameled lid, this grill resists rust and wear, ensuring longevity. The grill cart features sturdy wheels that allow for easy mobility, making it simple to relocate the grill as needed and store it away after use.

Another notable aspect is the integrated thermometer, which is conveniently installed on the lid. This feature provides real-time temperature reading, so you can monitor the heat without lifting the lid and interrupting the cooking process. The side tables provide ample workspace for food preparation and feature tool hooks for easy access to grilling utensils, enhancing the functionality of the grill.

The Spirit 54265 is designed for natural gas use, and it comes with a connection hose and natural gas regulator, making it easy to set up for outdoor cooking without worrying about running out of fuel. The grill's design is not only focused on performance but also on aesthetics, featuring sleek, modern lines that enhance any outdoor space.

In summary, the Weber 54265 Spirit Natural Gas Grill is an exceptional choice for anyone looking to elevate their grilling experience. With its powerful performance, user-friendly features, and durable construction, it promises to deliver delicious grilled dishes with ease and efficiency. Whether you’re a weekend warrior or a casual griller, this grill is sure to impress with its quality and capabilities.
Top Page Image Contents