Invacare R2-250, Pronto R2 manual Table of Contents

Page 3

TABLE OF CONTENTS

TABLE OF CONTENTS

NOTE: The following procedures refer to the ProntoR2 and the ProntoR2-250 Series.

T A

SPECIAL NOTES	2
SPECIFICATIONS	4
PROCEDURE 1 - GENERAL GUIDELINES	5
REPAIR OR SERVICE INFORMATION	5
OPERATING INFORMATION	5
SAFETY/HANDLING OF WHEELCHAIRS	7
WARNING/CAUTION LABEL LOCATION	10
BATTERY BOX SHIPPING INSERTS	11
PROCEDURE 2 - SAFETY INSPECTION
CHECKLIST/TROUBLESHOOTING	12
SAFETY INSPECTION CHECKLIST	12
TROUBLESHOOTING GUIDE - MECHANICAL ..	13
TROUBLESHOOTING GUIDE - ELECTRICAL...	13
CHECKING BATTERY CHARGE LEVEL	13

PROCEDURE 5 - CAPTAIN'S SEAT/
POSITIONING STRAP	29
ADJUSTING CAPTAIN'S SEAT	29
REPLACING SEAT POSITIONING STRAP	29
PROCEDURE 6 - ELECTRONICS	30
PREPARING MKIV JOYSTICK FOR USE	30
REPOSITIONING MKIV JOYSTICK	30
DISCONNECTING/CONNECTING LIMIT
SWITCH	31
REPOSITIONING BATTERY CHARGER
CONNECTOR	31
FUSE REPLACEMENT	31
PROCEDURE 7 - RETAINING STRAP	32
REPLACING BATTERY BOX RETAINING
STRAP	32

B

L E

O F

C O N T E N T S

PROCEDURE 3 - FRONT RIGGINGS	15
INSTALLING/REMOVING FOOTRESTS	15
ADJUSTING FOOTREST HEIGHT	15
REPLACING HEEL LOOPS	16
INSTALLING/REMOVING ELEVATING
LEGRESTS	16
RAISING/LOWERING ELEVATING LEGRESTS
AND/OR ADJUSTING CALFPADS	17
ADJUSTING/REPLACING TELESCOPING
FRONT RIGGING SUPPORT	17
ADJUSTING REMOVABLE FOOTBOARD	18
REMOVING THE REMOVABLE
FOOTBOARD ASSEMBLY FROM THE
WHEELCHAIR	19
INSTALLING/REMOVING THE ONE PIECE
FOOTBOARD	20
ADJUSTING THE ONE PIECE FOOTBOARD -
HEIGHT, ANGLE AND DEPTH	20
REMOVING/INSTALLING THE CALF-PADS	21
ADJUSTING THE CALF-PADS	21
FOOTREST ANGLE ADJUSTMENTS	26
PROCEDURE 4 - ARMS	27
INSTALLING/REMOVING FLIP BACK
ARMRESTS	27
ADJUSTING FLIP BACK ARMRESTS	27
ADJUSTING CAPTAIN'S SEAT ARMRESTS	28

PROCEDURE 8 - WHEELS	33
ENGAGING/DISENGAGING MOTORS
WITH CLUTCHES	33
ENGAGING/DISENGAGING MOTORS
WITH MOTOR LOCKS	33
ADJUSTING FORKS	34
ADJUSTING THE STABALIZER	34
PROCEDURE 9 - SHROUDS	35
REMOVING/INSTALLING SHROUDS	35
PROCEDURE 10 - RECLINER	36
RECLINER OPERATION	36
REPLACING BACK OR HEADREST
UPHOLSTERY	36
ADJUSTING BACK OR HEADREST
UPHOLSTERY	37
PROCEDURE 11 - BATTERIES	38
INSTALLING/REMOVING BATTERIES INTO/
FROM BATTERY BOXES	38
CONNECTING BATTERY CABLES	39
WHEN TO CHARGE BATTERIES	43
CHARGING BATTERIES	43
REPLACING BATTERIES	45
INSTALLING/REMOVING BATTERY BOXES ....	45
INSTALLING/REMOVING BATTERY TRAY	46
LIMITED WARRANTY	47

3

Image 3

Contents ProntoR2/Pronto R2-250 Series Wheelchair TIE-DOWN Restraints and Seat Positioning Straps R N I N GTable of Contents Performance Specification SWeight limitation varies with motor. Refer to Rain and operators weightGeneral Guidelines ProcedureGeneral Guidelines ProcedureGeneral Guidelines Remove the occupant from the wheelchair SAFETY/HANDLING WheelchairsStability and Balance StairwaysReaching, Leaning, Bending and Bending Forward Shift body weight into seat with transferMinimize GAP Distance Functional Reach From a WheelchairReaching, Bending Backward Shipping Insert Installed Shipping Insert Battery BoxShipping Insert Removed Safety INSPECTION/TROUBLESHOOTING Safety Inspection ChecklistSafety INSPECTION/TROUBLESHOOTINGPROCEDURE Troubleshooting MechanicalTroubleshooting Electrical Checking Battery Charge LevelUsing Hydrometer to Check Battery Cells Lead Acid Figure Number of Floating BallsNumber of Floating Balls Will Vary According to Charge O N T INSTALLING/REMOVING Footrests FigureAdjusting Footrest Height Front RiggingsO N T I N G S INSTALLING/REMOVING Elevating Legrests FigureProcedure Front Riggings Replacing Heel Loops FigureReplacing Adjusting CalfpadsAdjusting Raising/Lowering Elevating LegrestsHeight Figure Adjusting Removable FootboardDepth Figure Angle FigureRemoving The Removable Footboard Plate Installing The Removable Footboard PlateRemoving the One Piece Footboard INSTALLING/REMOVING the ONE Piece Footboard FigureAdjusting the ONE Piece Footboard HEIGHT, ANGLE, and Depth Installing the One Piece FootboardFlat Head Screws Heel Mounting Holes Footboard REMOVING/INSTALLING the CALF-PADS FigureAdjusting the CALF-PADS Adjusting the Calf-Pad Height FigureHub Cap Adjusting the Calf-Pad Width FigureAdjusting the Calf Pad Angle Figure Locknut Caplug WasherRemove the two 2 hub caps from the pivot bracket Adjusting the Calf-Pad DepthCalf-Pad Bracket Locknuts Pivot Calf-Pad Legrest TubeNylon Small WashersO N T I N G Footrest Angle Adjustments Figure M S INSTALLING/REMOVING Flip Back Armrests FigureAdjusting Flip Back Armrests Figure ArmsPositioning Flip Back Armrests for Use Adjusting Captains Seat ArmrestsProcedure Arms Adjust top of the flip back armrest to the desired heightP T a I N S Adjusting Captains Seat FigureReplacing Seat Positioning Strap Captains SEAT/POSITIONING StrapE C Adjustable Seat Back Angle/Recliner Seat Models FigureRepositioning Mkiv Joystick Preparing Mkiv Joystick for USE FigureE C T R O N I C S Fuse Replacement FigureRepositioning Battery Charger Connector Figure ElectronicsRetaining Strap Replacing Battery BOX Retaining Strap FigureT a R a POutside of Wheelchair Front of Wheelchair ENGAGING/DISENGAGINGMOTORS with Clutches Figures 1ENGAGING/DISENGAGING Motors with Motor Locks Figure WheelsAdjusting Forks Figure Adjusting the Stabilizer Figure Additional Adjustments for User Preference Detail BWheels REMOVING/INSTALLING Shrouds Figure ShroudsR O U D S Recliner Recliner Operation FigureReplacing Back or Headrest Upholstery Figure C L I N E RCane Upholstery Adjusting Back or Headrest Upholstery FigureRecliner Headrest Upholstery ExtensionBatteries T T E R I E SDual U1 Batteries Connecting Battery CablesBatteries Direct Mount MethodConnect Battery Cable to Battery Terminal AS Shown Connect Battery Cables Ring Terminals to This Side PostsBlack battery clamp cover onto Black bat- tery cable Installing Battery Clamp CoversInstall the battery box tops Detail a Connecting Battery Cables to Batteryies TERMINALS/POSTSRED Battery Clamp Cover Negative Battery Terminal/Post Tie-Wrap Group 22NF BatteryMkiv RII Joystick When to Charge Batteries FigureDescription and Use of Battery Chargers Charging Batteries FigureRequired Items Detail aDetail B Replacing Batteries INSTALLING/REMOVING Battery Boxes FigureRecommended Battery Types Cleaning Battery TerminalsStrap Clip One 1 Connector Battery BoxRear of Chair Retaining FrontR R a N T Y WarrantyUSA