Craftsman 919.72427 owner manual Typical Compressed AIR Distribution System

Page 12

•Use pipe that is the same size as the air tank outlet. Piping that is too small will restrict the flow of air.

•If piping is over 100 feet long, use the next larger size.

•Bury underground lines below the frost line and avoid pockets where condensation can gather and freeze. Apply pressure before underground lines are covered to make sure all pipe joints are free of leaks.

•A flexible coupling is recommended to be installed between the air discharge outlet and main air distribution line to allow for vibration.

•A separate regulator is recommended to control the air pressure. Air pressure from the tank is usually to high for individual air driven tools.

	AIR FLOW	FEEDER LINES SLOPE
		WITH AIR FLOW	AIR FLOW

MAIN DISTRIBUTION AIR LINES Slope pipe in direction of air flow. Water condensate flows along bottom of pipe to drain legs, preventing it from entering feeder lines.

REGULATOR

LUBRICATOR

DRAIN

TRAP

MOISTURE

SEPARATOR

AND TRAP

AIR USAGE

LINES

DIRT

LEG

FILTER

FLEXIBLE

COUPLING

DRAIN

LEGS

DRAIN

TRAPS

REGULATOR

LUBRICATOR

AIR DISCHARGE

DIRTVALVE LEG

AIR

COMPRESSOR

TYPICAL COMPRESSED

AIR DISTRIBUTION SYSTEM

DRAIN COCK

VALVE

D24450

12- ENG

Image 12

Contents AIR Compressor Sold by Sears Canada, Inc. Toronto, Ont. M5B 2B8Table of Contents Specification Chart Safety Guidelines DefinitionsImportant Safety Instructions Model No 919-724270Hazard Risk of Explosion or FireRisk of Bursting Risk from Flying ObjectsRisk of Electrical Shock Risk to BreathingRisk of Burns Risk from Moving PartsRisk of Falling Risk of Unsafe Operation Accessories AccessoriesGlossary Duty CycleAssembly InstallationWiring Instructions Voltage and Circuit ProtectionAir Distribution System Risk of ElectricalTypical Compressed AIR Distribution System Operation Know Your Air CompressorDescription of Operation Drain ValveHow to Stop Before StartingCheck Valve Pressure Release ValveHow to Start Before Each Start-UpMaintenance To Check Safety ValveCustomer Responsibilities To Drain TankAir Filter Inspection and Replacement Air Compressor Pump Intake and Exhaust ValvesInspect Air Lines and Fittings for Leaks MotorService and Adjustments To Replace or Clean Check ValveNut Outlet Tube Pressure Relief Check Valve Screwdriver Open position nothing is visibleStorage Troubleshooting Problem Cause CorrectionProblem Cause Correction Check wiring connection Table DES Matières Sears Canada, Inc., Toronto, Ont. M5B 2B8Tableau DES Spécifications Mesures DE Sécurité DéfinitionsConsignes DE Sécurité Importantes Risque D’EXPLOSION OU D’INCENDIE RisqueRisque D’ÉCLATEMENT Risque DE Projection D’OBJETSRisque DE Choc Électrique Risque PAR InhalationRisque DE Brûlures Risque Relié AUX Pièces MobilesRisque DE Chute Risque Dune Utilisation Dangereuse Accessoires Cycle DE ServiceAccessoires LexiqueAssemblage Directives de câblage Directives DE Mise À LA TerreTension et protection des circuits Système de distribution dairSystème DE Distribution Dair Typique Utilisation Familiarisez-vous avec votre compresseur dairDescription du fonctionnement Utilisation de lappareil Avant le démarrageArrêt de lappareil Procédures de rodageAvant chaque mise en marche Mise en marcheEntretien Responsabilités du clientVérification de la soupape de sûreté Vidange du réservoirFiltre à air Inspection et remplacement MoteurFiltre à air Remplacement ou nettoyage de la soupape de retenue Entretien ET RéglagesRangement Dépannage Problème Cause CorrectionSerrer Peut éclater ou exploserCognements Pas Surcharges déclenché Remarque ENG D24450 Get it fixed, at your home or ours