Mr. Heater MH25NG/LP, HS25NG/LP owner manual Table of Contents

Page 2

WARNINGS

WARNING: Improper installation, adjustment, alteration, service or maintenance can cause property damage, injury or death. Read the installation, operation, and maintenance instruc- tions thoroughly before installing or servicing this equipment. For assistance or additional informa- tion consult a qualified installer, service agency, or gas supplier.­

WARNING: When used without fresh air, heater may give off CARBON MONOXIDE, an odorless poisonous gas. OPEN WINDOW AN INCH OR TWO FOR FRESH AIR WHEN USING HEATER.

WARNING: This heater is equipped with a PILOT LIGHT SAFETY SYSTEM. DO NOT TAMPER WITH PILOT LIGHT SAFETY SYSTEM.

WARNING: If heater shuts off, do not relight until you provide fresh air. If heater keeps shutting off, have it serviced. Keep burner and control clean. Open door for 5 minutes.

Maintain clearances as shown in Figure 2 or on heater nameplate.

•DO NOT USE MATCH OR OTHER FLAME FOR LEAK TESTING.

•DO NOT EXCEED 1/2 PSI INLET PRES- SURE TO HEATER.

DANGER: Carbon monoxide poisoning may lead to death.­

Carbon Monoxide Poisoning:

Early signs of carbon monoxide poisoning resemble the flu, with headaches, dizziness, or nausea. If you have these signs, the heater may not be working properly. Get fresh air at once! Have heater serviced. Some people are more affected by carbon monoxide than oth- ers. These include pregnant women, persons with heart or lung disease or anemia, those under the influence of alcohol, and those at high altitudes.

CAUTION

•Never connect gas valve or thermostat to line volt- age or a transformer.

•If the infra-red color of the grid becomes dull when the building furnace is operating, consult gas sup- plier on correct gas supply piping sizes.

•This heater is for indoor installation only!

NOTE

Gasket binder material used in this heater assembly will temporarily emit an odor and/or vapor. This condition will clear up in approximately 20 minutes and thereafter will not reoccur. Refer to Chapter 2 for ventilation.

WARNING:

The State of California requires the following warning:

COMBUSTION BY-PRODUCTS PRODUCED WHEN USING THIS PRODUCT CONTAIN CAR- BON MONOXIDE, A CHEMICAL KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER AND BIRTH DEFECTS (OR OTHER REPRODUC- TIVE HARM).

TABLE OF CONTENTS

Chapter

Title

Page

I

Introduction.

............................................

E3

II

Heater Installation

E5

III

Heater Operating Instructions

E10

IV

Operator Maintenance Instructions

E12

V

Replacement Parts List

E15

Model # MH25NG/LP

HS25NG/LP

E2

Installation instructions and Owner’s Manual

Page 1 Page 3
Image 2
Page 1 Page 3
Contents Spanish GAS Fired INFRA-RED Workshop HeaterEnglish FrenchTable of Contents Purpose of Equipment Chapter IntroductionEquipment General Information Heater Dimensions and Orifice SizesSee Tables 1 and 2 for heater specifications BTU Ratings and Supply PressuresOnly Flue Side of Heater can Chapter Heater InstallationGeneral Installation Information and Requirements Heater Side Reflector MustHeater Mounting Instructions Heater Mounting Information Gas Supply Requirements Connecting Heater to GAS SupplyPiping Installation Piping RequirementsTypical Piping Installation Chapter Heater Operating Instructions Operating Safety Instructions Heater StartupFlame for Leak Testing PressureHeater Shutdown Lighting of Pilot BurnerAdjusting the Pilot Flame Chapter Operator Maintenance InstructionsTroubleshooting ER Unit Beneath Cover ScrewFrequency of Operator Checks Symptoms Causes SolutionsReplacing the GAS Valve Unit If Service is Required Please do not Return this Appliance to Your StoreChapter Replacement Parts List ALL Warranty Claims Require Proof of PurchaseFor Information Regarding Service or Parts For Additional InformationCalentador Infrarrojo a GAS Para Taller QUÉ Hacer SI Detecta Olor a GASAviso AdvertenciasIntoxicación por monóxido de carbono ÍndiceFinalidad DEL Equipo Advertencias Capítulo IntroducciónEquipo Tabla 1. Índices en BTU y presiones de suministro Tabla 2. Dimensiones del calentador y tamaños de orificioInformación General Número Tema relacionadoCapítulo Instalación DEL Calentador Información Y Requisitos Generales DE InstalaciónInstrucciones DE Montaje DEL Calentador Conexión DEL Calentador AL Suministro DE GAS Requisitos para el suministro de gasUSE UNA Cantidad Moderada DE Sellador Para Conductos Requisitos relativos a los conductosInstalación de conductos Encendido DEL Calentador Figura 7. Instalación característica de los conductosNota Capítulo Instrucciones DE Funcionamiento DEL CalentadorInstrucciones DE Funcionamiento Seguro Apagado DEL Calentador Capítulo Instrucciones DE Mantenimiento Para EL OperadorNota Reparación DE AveríasAjuste DE LA Llama DEL Piloto Figura 11. Ajuste correcto de la llamaFrecuencia DE LOS Controles DEL Operador Síntomas Causas SolucionesCambio DE LA Unidad DE LA Válvula DE GAS SI Debe Repararlo No Devuelva EL Artefacto a LA TiendaCapítulo Lista DE Repuestos Para Obtener Información Sobre Reparación O Repuestos Instruccionesde Funcionamientoy Manualdel UsuarioAdvertencia Para Obtener MÁS InformaciónRadiateur D’ATELIER À Infrarouge Alimenté AU GAZ EN Présence D’UNE Odeur DE GAZMise EN Garde AvertissementsEmpoisonnement au monoxyde de carbone Table DES MatièresUtilisation DE L’ÉQUIPEMENT Avertissements Chapitre IntroductionÉquipement Tableau 1. Puissances en BTU et pressions d’alimentation Tableau 2. Dimensions du radiateur et tailles des orificesRenseignements Généraux Puissance Chapitre Installation DU RadiateurLE Réflecteur Latéral DU Radiateur Doit Être Horizontal Instructions DE Montage DU Radiateur Directives de montage du radiateur Exigences relatives à l’alimentation en gaz Installation des tuyauxConnexion DU Radiateur À L’ALIMENTATION EN GAZ Exigences relatives à la tuyauterieInstallation type de la Tuyauterie Cm 3 poChapitre Radiateur Consignes DE SécuritéArrêt DU Radiateur Allumage de la veilleuseRéglage DE LA Flamme DE LA Veilleuse Chapitre Directives D’ENTRETIEN ’INTENTION DE L’UTILISATEURDépannage Réglage AP Proprié DE LA 10 À 13 Millimètres FlammeFréquence DES Inspections PAR L’UTILISATEUR Symptômes Causes SolutionsRemplacement DE LA Soupape DE GAZ SI UNE Réparation EST Nécessaire NE Retournez PAS CET Appareil À Votre Magasin’ARTICLE DE Nomen Description Clature Informations SUR LA Commande DE Pièces

HS25NG/LP, MH25NG/LP specifications

The Mr. Heater HS25NG/LP and MH25NG/LP are reliable and efficient heating solutions designed for both residential and commercial spaces. These powerful units deliver warmth and comfort, making them ideal for garages, workshops, and outdoor settings.

One of the standout features of the HS25NG and MH25NG is their versatility in fuel options. The HS25NG is designed to use natural gas, while the MH25NG operates on propane, providing flexibility based on user needs and availability. This adaptability allows users to select the most convenient and cost-effective energy source for their heating requirements.

Both models are equipped with a robust heat output, with the capability to deliver 25,000 BTUs per hour. This level of performance ensures quick heating even in larger spaces, establishing a comfortable environment in minimal time. The units also feature a wide heating area that can efficiently cover spaces up to 600 square feet, making them suited for various applications.

User safety and efficiency are paramount in the design of these heaters. The HS25NG and MH25NG come with an automatic shutoff system that activates if the unit tips over or detects any obstruction to airflow. Additionally, they are equipped with a built-in piezo ignition system, enabling easy and reliable lighting without the need for matches or an external ignition source.

The heaters also incorporate advanced technology to optimize performance. Their infrared heating design allows for direct and efficient warmth, minimizing energy loss and ensuring that heat is directed where it's needed most. This not only enhances efficiency but can also lead to reduced energy costs over time.

Both models are designed with portability in mind, featuring a lightweight construction and convenient carry handle, making it simple to move the unit from one location to another as needed. The durable construction ensures that they can withstand the rigors of frequent use, whether it be in a workshop or an outdoor gathering.

In summary, the Mr. Heater HS25NG/LP and MH25NG/LP are powerful, versatile, and reliable heating solutions that combine advanced technology with user-friendly features. With their strong heat output, safety features, and option for both natural gas and propane, these heaters are an excellent choice for those looking for efficient heating in any environment.
Top Page Image Contents