Monessen Hearth WDV500 PRE-INSTALLATION Information, Fireplace Location, Cold Climate Insulation

Page 7

PRE-INSTALLATION INFORMATION

WDV Series Gas Fireplace

 

 

Fireplace Location

Plan for the installation of your appliance. This includes determining where the unit is to be installed, the vent configuration to be used, framing and finishing details, and whether any optional accessories (i.e. blower, wall switch, or remote control) are desired. Consult your local building code agency to ensure compliance with local codes, including permits and inspections.

The following factors should be taken into consideration:

•Clearance to side-wall, ceiling, woodwork, and windows. Minimum clearances to combustibles must be maintained.

•This fireplace may be installed along a wall, across a corner, or use an exterior chase. See Figure 3 for suggested locations.

•Location should be out of high traffic areas and away from furniture and draperies due to heat from appliance.

•Never obstruct the front opening of the fireplace.

•Do not install in the vicinity where gasoline or other flammable liquids may be stored.

•Vent pipe routing. See Venting section found in this manual for allowable venting configura- tions.

•These units can be installed in a bedroom. Refer to the National Fuel Gas Code ANSI Z233.1/ NFPA 54 — (current edition), the Uniform Mechanical Code — (current edition), and Local Building Codes for specific installation requirements.

•These units can be installed in a bathroom.

 

 

 

 

A

Flat on Wall

 

 

 

 

B

Cross Corner

 

E

A

 

C

Island**

Y

 

D

Room Divider*

 

 

 

 

 

 

E

Flat on Wall Corner*

 

 

 

 

 

 

C

X

F

Chase Installation

 

 

 

Y

4" Minimum

 

 

 

 

 

D

 

 

** Island (C) and room divider (D) installation is possible as long

Y

 

 

B

as the horizontal portion of vent system (X) does not exceed

 

 

 

20'. Refer to Installing Horizontal Termination Configuration on

 

 

 

 

 

 

F

 

 

 

Page 12.

 

 

 

* When you install your fireplace in (D) room divider or (E) flat

 

 

 

 

 

 

 

 

 

on wall corner positions (Y), a minimum of 6" clearance must

 

 

 

 

 

be maintained from perpendicular wall and front of fireplace.

Figure 3 -

 

 

 

 

Possible Fireplace Locations

 

 

 

NOTE

COLD CLIMATE INSULATION

If you live in a cold climate, seal all cracks around your appliance, and wherever cold air could enter the room, with noncombustible material. It is especially important to insulate the outside chase cavity between the studs and under the floor on which the appliance rests, if the floor is above ground level.

78D0011

Page 6 Page 8
Image 7
Page 6 Page 8
Contents WDV Wideview Direct Vent Gas Fireplace Operating Instructions Signature Command SystemInstaller Important Safety InformationOwner As wellhead gas Code ApprovalNever connect unit to private non-utility Gas wells. This gas is commonly knownHigh Elevations Product features and code approvalFireplace and Framing Dimensions Fireplace & Framing DimensionsFireplace Location PRE-INSTALLATION InformationCold Climate Insulation Side View ClearancesClearances to combustibles Mantel clearancesFront face of fireplace Never install combustible materials overSecure Fireplace to floor or framing Finishing MaterialFailure to follow these instructions will Venting Installation InformationInstallation precautions Void the warrantyFor horizontal termination Vent installationInstallation planning Installing a vent system in an outside chaseMinimum distances Venting installationAir Supply Inlet Area Where Terminals Not Permitted For horizontal termination Inside Corner DetailHow To Use The Vent Graph Venting installationMaximum Three 3 90 Elbows Per Installation VERTICAL/Horizontal termination configurationsWall Below Grade InstallationsMaintained between the snorkel Vertical through-the-roof applicationsDo not back fill around snorkel Clearance of at least 4 must beFlat ceiling installation Venting installation Installation for vertical terminationTermination Heights for Vents Above Flat or Sloped Roofs Flex Vent Installation Flex Vent Installation Check gas type Fireplace installationInstalling gas piping to fireplace location Installation items neededPropane/LP Natural GasDo not use open flame to check for gas leaks Electrical WiringImproper and dangerous operation Caut NIO AW RNI GN Command Center Wall InstallationWiring to junction box Signature command Optional fan blower systemOptional Fan/Blower System Blotbldvsc Light Installation Glass removal & light placementGlass Frame Removal Stone & Glass Placement Stone & glass placementGlass only Placement What to do if YOU Smell GAS Signature command Operating InstructionsOPERATing Instructions Switch BoxBattery Installation FeaturesFunction Operation Default Setting Signature Command System Operation InstructionsSystem CONFIGURATION/SETUP Key Combinations for System SettingsFault LeD Indication Command Center FUNCTIONS/OPERATIONCommand Center Operations Self Diagnostics ChartRemote Transmitter Operations Remote Control OperationSpeed Blower Control Optional Flame Height Setting for Thermostatic ModeLevel Light Brightness Control Child-Proof Protection Remote Control OperationLow Battery Detection ON/OFF AUX Control OptionalBurner, Pilot and Control Compartment Cleaning and maintenanceGlass Door Vent SysteMStones Signature Command System TroubleshootingDescription Qty WDV500 Replacement PartsFirebox components and accessories Accessories / Field Installed OptionsReplacement Parts LP to Natural Gas Replacement PartsVent components Current Old Simpson Duravent Vent Components for 5 XOr Mhsc Selkirk Box Description Stones WDV Series Gas Fireplace Manufacturer Requirements MassachusettsIf Warranty Service is Needed Lifetime WarrantyFive Year Warranty Basic WarrantyModel Mhsc

WDV500 specifications

The Monessen Hearth WDV500 is a stylish and efficient direct vent gas fireplace designed to enhance any living space. This fireplace combines modern aesthetics with advanced technology to create a cozy atmosphere while ensuring optimal performance. With its sleek design and versatile installation options, it caters to various home styles, making it an ideal choice for homeowners looking to elevate their ambiance.

One of the standout features of the WDV500 is its direct vent system, which allows for safe and efficient operation. This system utilizes outside air for combustion, ensuring that indoor air quality is maintained. By drawing air from the outside and venting exhaust gases directly outside, the WDV500 minimizes heat loss and maximizes energy efficiency. This makes it an environmentally friendly option, aligning with contemporary sustainability practices.

The Monessen Hearth WDV500 is equipped with a variety of innovative technologies aimed at providing users with ease of use and improved functionality. The adjustable flame control allows homeowners to customize the intensity of the fire to suit their mood or occasion. Additionally, the WDV500 features a high-efficiency burner that generates an impressive heat output, ensuring that rooms are kept warm and inviting even during the coldest months.

In terms of design, the WDV500 offers multiple finish options and accessory features, allowing it to seamlessly blend into any decor. A stunning selection of logs, crystals, or stones enhances the visual appeal of the fireplace, giving it a contemporary touch that complements traditional or modern interiors alike.

Safety is a priority with the Monessen Hearth WDV500, which includes an automatic shut-off feature that engages if the unit experiences overheating, ensuring peace of mind for users. The fireplace's straightforward installation process further emphasizes its user-friendly design, suitable for both new builds and retrofitting into existing spaces.

Overall, the Monessen Hearth WDV500 represents a harmonious blend of technology, safety, and style. Whether for relaxation on chilly evenings or for entertaining guests, this versatile fireplace provides warmth and elegance, making it a perfect addition to any home. Its efficient performance, customizable features, and aesthetic appeal make the WDV500 a popular choice among discerning homeowners.
Top Page Image Contents