Monessen Hearth C2801VF, C2804VF, C2802VF Getting Started, Make Sure You Have Received All Parts

Page 6

GETTING STARTED

GETTING STARTED

MAKE SURE YOU HAVE RECEIVED ALL PARTS:

Check your packing list to verify that all listed parts have been received. You should have the following:

•Cast Iron Stove with Burner Assembly

•Installation/Operating Instructions

•Ceramic fiber logs

•Four (4) Leg Levelers

•Touch-up Paint

Millivolt controlled heater designed to be operated with optional devices for ON/OFF functions.

•Hand-Held Remote with Receiver, Manual or Thermostat

•Wall Switch with 15' Wire

•Wall T-stat with15' Wire

•Stove Mounted Thermostat Control

CAUTION

Handle the gas log burner assembly by the grate only. Do not pick the unit up by the burners.

Gloves are recommended when handling ceramic fiber logs to prevent skin irritation from loose fibers. Logs are fragile--handle with care.

Carefully inspect the contents for shipping damage. If any parts are missing or damaged, immediately inform the dealer from whom you purchased the appliance. Do not attempt to install any part of the appliance unless you have all parts in good condition.

WHAT YOU WILL NEED FOR INSTALLATION:

You must have the following items available before proceeding with installation:

•External regulator (for propane/L.P.G.) or high pressure natural gas (1 to 2 PSI system)

•Piping which complies with local codes

•Pipe sealant approved for use with propane/L.P.G. (Resistant to sulfur compounds)

•Manual shutoff valve

•Sediment trap (recommended)

•Tee joint

•Pipe wrench or appropriate wrench set

•Screwdrivers

6

45D0080

Image 6

Contents WHAT TO DO IF YOU SMELL GAS MODELS C2801VF, C2802VF C2803VF, and C2804VFNatural Gas or Propane/LPG Milli-VoltControl Do not try to light any applianceCONTENTS IMPORTANT SAFETY INFORMATION INSTALLEROWNER IMPORTANT SAFETY INFORMATION Continued from pageOptional Remote Receiver Off/Pilot/On Knob PRODUCT FEATURESOn/Off Switch Data andOptional Instruction Thermostat Plates Sensor Hi/Lo KnobWHAT YOU WILL NEED FOR INSTALLATION GETTING STARTEDMAKE SURE YOU HAVE RECEIVED ALL PARTS PROPANE / LPG PRODUCT SPECIFICATIONSNATURAL GAS IGNITION CONTROLS•In high traffic areas •In windy or drafty areas GENERAL INSTALLATION INFORMATIONDo not install the heater … CODESGENERAL INSTALLATION INFORMATION BTU/Hr = L1CLEARANCES / HEIGHT REQUIRMENTS Corner InstallationWall Installation Front ViewCONNECTING THE GAS Figure 4 - Gas Connectionpropane/L.P.G. tank can cause an Connecting directly to an unregulatedCONNECTING REMOTE RECEIVER explosionCONNECTING OPTIONAL WALL SWITCH OR THERMOSTAT ELECTRICAL WIRING MILLI-VOLTFigure 7 - Wiring Diagram MillivoltELECTRICAL WIRING MILLI-VOLT Figure 8 - Removing Face Plate from StoveScrews Figure 10 - Clipping Thermo Bulb into OPERATION OF THERMOSTAT SENSORELECTRICAL WIRING MILLI-VOLT Plastic Cliparound the pilot. This may cause sooting LOG PLACEMENTDO NOT sprinkle volcanic rocks on the logs or a few hours to vent the odorOPERATING INSTRUCTIONS FLAME APPEARANCECHECKING BURNER FLAME CHECKING PILOT FLAMEFOR YOUR SAFETY READ BEFORE LIGHTING OPERATING INSTRUCTIONSWHAT TO DO IF YOU SMELL GAS MILLI-VOLTCONTROL LIGHTING INSTRUCTIONS TO TURN OFF GAS TO HEATEROPERATING INSTRUCTIONS OPERATING INSTRUCTIONS AND CLEANING AND SERVICING CLEANING AND SERVICINGMATCH LIGHTING INSTRUCTIONS REPLACEMENT PARTS LIST LOGSDescription REPLACEMENT PARTS BURNER ASSEMBLY45D0080 Accessories REPLACEMENT PARTS LISTBURNER ASSEMBLY C2801/02/03/04VFPOSSIBLE CAUSE TROUBLESHOOTINGOBSERVED PROBLEM REMEDYPOSSIBLE CAUSE TROUBLESHOOTINGOBSERVED PROBLEM REMEDY45D0080 45D0080 FIVE YEAR WARRANTY LIMITED LIFETIME WARRANTY POLICYLIFETIME WARRANTY BASIC WARRANTY