Amana AMV9, ACV9 installation instructions North Loop West, Suite Houston, TX

Page 40

®is a trademark of Maytag Corporation and is used under

license to Goodman Company, L.P. All rights reserved.

2550 North Loop West, Suite 400

Houston, TX 77092

www.amana-hac.com

© 2004-2006 Goodman Company, L.P.

40

Image 40

Contents RECOGNIZE THIS SYMBOL AS A SAFETY PRECAUTION ATTENTION INSTALLING PERSONNELINSTALLATION INSTRUCTIONS Installer Affix all manuals adjacent to the unitTable of Contents APPENDIX Table of ContentsCARBON MONOXIDE POISONING HAZARD WHAT TO DO IF YOU SMELL GASBLOWER COMPARTMENT BURNER COMPARTMENT BURNER COMPARTMENT BLOWER COMPARTMENTUpflow/Horizontal Counterflow/HorizontalII. SAFETY III.PRODUCT APPLICATIONIV. LOCATION REQUIREMENTS & CONSIDERATIONS Suspended Furnace Thermostat Influences V. COMBUSTION & VENTILATION AIR REQUIREMENTS5.3.1General 5.3.2Equipment Located in Unconfined SpacesBuilding. See 5.3.3-a 5.3.4Specially Engineered Installations VI. INSTALLATION POSITIONS5.3.5 Louvers and Grilles VII. HORIZONTAL APPLICATIONS & CONSIDERATIONSVIII. PROPANE GAS /HIGH ALTITUDE INSTALLATIONS Recommended Installation PositionsIX. VENT/FLUE PIPE & COMBUSTION AIR PIPE Vent Termination Clearances Vent/Flue Pipe Cuts Counterflow units2.Upflow and Counterflow units 3.Upflow and Counterflow units7.Upflow and Counterflow units 8.Upflow and Counterflow unitsCounterflow units Counterflow unitsAlternate Combustion Air Intake Location Vertical Termination Single PipeAlternate Vertical Termination Single Pipe UPFLOWHorizontal Termination Single Pipe Horizontal Termination Single PipeStandard Horizontal Terminations Dual Pipe Alternate Horizontal Vent Termination Dual PipeLevel Dual Pipe Dual PipeHose and Tube Identification Upright “Standard” Connections - Right SideUpflow Shown, Counterflow Similar Upright “Standard” Connections - Left SideUpright “Alternate” Connections - Right Side Only Upflow Shown, Counterflow SimilarHorizontal Connections - Right Side Down Upflow Shown, Counterflow SimilarUpflow Shown, Counterflow Similar Horizontal Connections - Left Side DownXI. ELECTRICAL CONNECTIONS 24 VOLT THERMOSTAT WIRING 24 VOLT DEHUMIDISTAT WIRINGTwo-StageHeating with Two-StageCooling Junction Box RelocationXII. GAS SUPPLY AND PIPING Inlet Gas Supply Pressure Gas Piping Connections Propane Gas Installation Typ Propane Gas Piping ChartPropane Gas Piping Chart XIII. CIRCULATING AIR & FILTERSPermanent Minimum Filter Area sq. in Duct Flange Cut OutsBased on a 600 ft/min filter face velocity XIV. STARTUP PROCEDURE & ADJUSTMENT Filter LocationsMeasuring Inlet Gas Pressure Alt. Method Temperature Rise Measurement ramping profile XV. NORMAL SEQUENCE OF OPERATION XVIII. TROUBLESHOOTING XVII. SAFETY CIRCUIT DESCRIPTIONFurnace awaits next call from thermostat XVI. OPERATIONAL CHECKSXIX. MAINTENANCE XXII. REPAIR & REPLACEMENT PARTS XXI. BEFORE LEAVING AN INSTALLATIONXX. INTERNAL FILTER REMOVAL Rollout Limit Switch Primary Limit SwitchAuxiliary Limit Switch Pressure SwitchTROUBLESHOOTING CHART Symptoms of AbnormalFault Descriptions Possible CausesTROUBLESHOOTING CHART Symptoms of AbnormalFault Descriptions Possible CausesWIRING DIAGRAM 2550 North Loop West, Suite Houston, TX