New Buck Corporation
1127B New Buck Corporation, Limited Warranty On Vent-Freegas Log Heater
Troubleshooting
Install
Repair Parts
Parts list
Wiring Diagram
Connecting To A Gas Supply
Problem
Manual Lighting Procedure
Cleaning Information
Log Placement For
Page 43
Page 42
Page 43
Image 43
Page 42
Page 43
Contents
8000 Highway 226 South Spruce Pine, NC
NEW BUCK CORPORATION
MODEL 1127B VENT-FREEGAS HEATER
Manufacturer NEW BUCK CORPORATION P.O. Box
Page
TABLE OF CONTENTS
Page
SAFETY INFORMATION WARNINGS
Do not try to light any appliance
21. . ”WARNING Failure to keep the primary air openings of the burners clean may result in sooting and property damage.”
PRODUCT IDENTIFICATION
PIEZO IGNITION SYSTEM
PRODUCT FEATURES
UNPACKING
SAFETY DEVICE
NOTE FOR GARAGE INSTALLATION
MINIMUM CLEARANCES TO COMBUSTIBLE CONSTRUCTION
For convenience and efficiency, install heater
3.Freestanding with optional wooden mantel
INSTALLATION
1.Wall Mounted
2.Freestanding heater with optional pedestal
CLEANING INFORMATION
FREESTANDING OPTIONAL WOODEN MANTEL INSTALLATION
FREESTANDING WITH OPTIONAL PEDESTAL INSTALLATION
OPTIONAL “L” BRACKETS 2 AND SCREWS 2 PRO
DETERMINING FRESH-AIRFLOW FOR HEATER LOCATION
PRODUCING ADEQUATE VENTILATION
Vent-freeheater
VENTILATION AIR FROM INSIDE BUILDING
VENTILATION AIR
VENTILATION AIR FROM OUTDOORS
FLAME
GAS CONNECTION
Propane Supply Tank
CONNECTING TO A GAS SUPPLY
External Regulator Vent Pointing Down
Installation must include manual shutoff valve and plugged 1/2 NPT tap. Locate NPT tap within reach for test gauge hook-up.NPT tap must be upstream from unit
GAS PRESSURE CHECK
Logs are shipped secured in unit
LOG PLACEMENT FOR
Front View of Logs
LIGHTING INSTRUCTIONS MODULATING VALVEMAXITROL
FOR YOUR SAFETY, READ BEFORE LIGHTING
OPERATING INSTRUCTIONS
for “HIGH”
LIGHTING INSTRUCTIONS
to IGNITE and
for “LOW”
IGNITER ELECTRODE THERMO-COUPLE
TO TURN OFF GAS TO APPLIANCE
O.D.S PILOT BURNER
THERMOSTAT CONTROL OPERATION
MANUAL LIGHTING PROCEDURE
FLAME CHECK
INCORRECT FLAME PATTERN AT HIGH POSITION
BURNER FLAME PATTERN
CORRECT FLAME PATTERN AT HIGH POSITION
Figure 1815 - Correct Burner Flame Pattern
JUMPERTHERMOSTAT
WIRING DIAGRAM
POWER CORD
MOTOR
SERVICING
REPAIR PARTS
CLEANING
IMPORTANT SAFEGUARDS
TROUBLE-SHOOTING
POSSIBLE
PROBLEM
SOLUTION
OBSERVED
1.Control knob is not fully pressed in
Delayed ignition of burner
1. Heater produces a clinking
MODEL 1127 - MODULATING VALVE
TECHNICAL SERVICE
PARTS LIST
MOTOR, AND ALL REMOVABLE PARTS
BLOWN UP VIEW OF HEATER, FAN
BURNER SYSTEM
PARTS LIST
BLOWN UP VIEW OF BURNER ASSEMBLY
NEW BUCK CORPORATION
LIMITED WARRANTY ON VENT-FREEGAS LOG HEATER
Related pages
All Warranty page
What Does this Warranty Cover? for Motorola C256
Warranty for Cybex International LT-14464-4 Rev H
Warranty for Marshall electronic V-R653P-HDSDI
Room AIR Conditioner Warranty for Frigidaire 220211A243
Warranty for Panasonic KX-TGA573S
Two-Year Limited Warranty for GE 106679
Warranty for Equator EW510
BUNN-O-MATIC Commercial Product Warranty for Bunn 2
Limited ONE Year Warranty for HoMedics WFL-SLVS
Soundpoint PRO Regulations and Warranty for Polycom SE-220
What does the
Beat Cut switch
do during recording?
Top
Page
Image
Contents