Lopi Endeavor owner manual Door Parts, Replacing the Glass, Replacing the Door Gasket

Page 27

Maintaining Your Appliance

27

Door Parts

7

1

8

14

12

13

1/8” Hex Wrench

# 20 Torx Driver

NOTE: Place the glass gasket around the perimeter of the door retainer.

NOTE: Glue the door gasket to the door retainer.

2

3

4

5

6

9 10

11

9/16" Wrench

ID #

Description

Qty

Part #

 

ID #

Description

Qty

Part #

1

Door Shell - Black

1

230-00570

 

2

Glass (15-3/8" x 8-7/8")

1

173-01002

 

Door Shell - Brass

 

230-00572

 

 

 

 

 

 

Door Shell - Pewter

 

230-00568

 

 

 

 

 

3

Glass Gasket

1

224-11086

 

4

Door Retainer (w gasket)

1

224-23020

5

Gasket Cement

1

99900409

 

6

Door Gasket

1

99900407

7

Door Handle Asbly - Black

1

224-14042

 

8

Spring - Black

1

100-14122

 

Door Handle Asbly - Brass

 

99900410

 

 

Spring - Brass

 

99300100

 

Door Handle Asbly - Pewter

 

224-14052

 

 

Spring - Pewter

 

100-04103

9

Washers

2

100-03501

 

10

Cam

1

99900417

11

Nut, Brass

1

101-00007

 

12

Glass Clips - Top

2

224-230022

 

 

 

 

 

 

Glass Clip - Bottom

1

224-230021

13

#8-32 3/8" Type F Screw

8

225-20039

 

14

Set Screw

2

225-20038

Replacing the Glass

The glass must not contact the door retainer or glass clips directly. The glass gasket and glass clip gaskets insulate the glass to prevent cracking. Do not over-tighten the glass clips.

See "Door Shell Installation" (pg. 32) for details on removing the door handle and shell. NOTE: The glass gasket is placed in the grove along the inside perimeter of the door retainer. Make sure the glass clip screws are all fully tightened - they must be flush with the door retainer for the door shell to install.

Replacing the Door Gasket

The door gasket inserts into the outer groove of the door retainer. Stove gasket cement holds it in place. Before installing, remove any residual cement. Lay the gasket in place (start at the lower left corner) and cut off any excess gasket (do not stretch the gasket. The cement fully cures with heat from the stove.

You may need to open and close the door repeatedly to get the gasket to seat fully.

Replacing the Door Handle

See the illustration above for a component list (see pg. 25 for details on adjusting the door).

© Travis Industries

100-01161

4040608

Image 27
Contents Endeavor Wood Stove Mail your Warranty Card Today, and Save Your Bill of Sale 2IntroductionIntroduction Important Information Table of Contents Ashes Safety PrecautionsMobile Travis Industries, Inc. grants no warranty, implied orFeatures & Specifications Stove Installation Considerations Planning The InstallationPreparation for Installation Additional Accessories Needed for InstallationClearances Stove Placement RequirementsMinimum Clearance Singlewall Reduced Connector Floor Protection RequirementsTop View Corner Installation Top View Straight InstallationChimney Requirements DraftingPerformance Outside Air Requirements Chimney Termination RequirementsAlcove Installation Requirements Mobile Home Requirements Cathedral Ceiling with a Factory Built Chimney Standard Ceiling with a Factory BuiltHearth Stove Positive Connection Exterior Factory Built ChimneyInterior or Exterior Masonry Chimney Hearth Stove Direct ConnectionOpening the Door Safety NoticeOperating Your Appliance Before Your First FireBypass Operation Starting a Fire Adjusting the Burn Rate Approximate Air Control SettingsAsh Removal Normal Operating Sounds Optional Blower OperationRe-Loading the Stove Overnight BurnWood Cutting and Storage Why Dry Wood is KeyHints for Burning Selecting WoodTroubleshooting Remove Ash if necessary Daily Maintenance while stove is in useClean the Glass if necessary Maintaining Your ApplianceMonthly Maintenance while appliance is in use Door and Glass InspectionCreosote Formation and Need for Removal Firebrick and Baffle Inspection Yearly MaintenanceCleaning the Air Duct and Blower if applicable Touch Up PaintReplacing the Door Handle Door PartsReplacing the Glass Replacing the Door GasketFirebox Parts Floor and Side Firebrick Removal & ReplacementAir Tube Removal & Replacement Baffle Removal & ReplacementYears 6 & 7 Coverage Parts only Limited 7 Year WarrantyYears 1 & 2 Coverage Parts & Labor Years 3 Through 5 Coverage Parts & LaborListing Label Listing InformationOptional Equipment Door Shell InstallationHex Wrench Stove Leg Installation Pedestal Using Outside Air with the PedestalInstall the wire clip following the directions below Rear Blower InstallationOutside Air Boot Installation Part number Index