Allstar Products Group J3500, 3000, 3500-P owner manual Component Identification, Tools Required

Page 4

COMPONENT IDENTIFICATION

DRIVE

CHAIN

TROLLEY
OUTER HALF	DOOR ARMS
	DOOR ARMS

	MASTER
OPENER HEAD UNIT	LINKS

ONE-PIECE SECTIONAL

DOORS DOORS

CHAIN

GUARD

WALL

MOUNTING BRACKET

DOOR MOUNTING

BRACKETS

RUBBER BUMPER

RELEASE ROPE

AND HANDLE

OPENER

HARDWARE

BAG

TEE RAIL

! W ARNING

Child can be pinned under automatic garage door. Death or serious injury can result.

•Never let child walk or run under moving door.

•Never let child use door opener controls.

•Always keep moving door in sight.

•If person is pinned, push control button or use emergency release.

•Test door opener monthly:

Refer to your owner’s manual

Place one-inch object (or 2x4 laid flat) on floor. If door fails to reverse on contact, adjust opener.

If opener still fails to reverse door, repair or replace opener.

PUSHBUTTON

“WARNING” LABEL

WALL PUSHBUTTON

	CHAIN LIMIT
FRONT IDLER	CAM
FRONT IDLER

ALL-CLEAR

PHOTOSYSTEM

ALL-CLEAR HARDWARE

TOOLS REQUIRED

HAMMER

DRILL

1/2” OPEN END

	HACKSAW
STEPLADDER	SOCKETWRENCH
	3/8” SOCKET
	7/16” SOCKET

DRILL & BITS

SMALL SCREW DRIVER

(1/8” HEAD)

WRENCH

LEVEL

WOOD	SCREW DRIVER
BLOCK	TAPE MEASURE
	TAPE MEASURE

4

Image 4

Contents Series Table of Contents Product Features Optional FeaturesComponent Identification Tools RequiredAssembly Instructions StepImportant Installation To Reduce the Risk of Severe Injury AdjustmentInstalling the Operator Do not Attempt AdjustmentMounting the Front Bracket One High ARC Rise High ARC Rise Horizontal LineMount Power Head to Ceiling Sectional Doors and One Piece Doors with TrackOne Piece Doors without Track Raise the opener Mounting straps in the slots closest to FrontDoor ARM Connection and Installation Connect the standard wall Push Button provided to Mount at least 5 FT from the floor to prevent small childrenFastening Limit CAM to Chain Photosystem Unit is Within the Limit Marks on the Door Jamb Auxiliary EquipmentConnect the Photosystem as follows Final Installation Final Alignment and TestInstallation of Radio Controls Operating Parameters Check with Your Local Building Inspector FirstIf the Door is ONE SECOND, and then Begin Moving Upward104390 Operation and Adjustment Instructions Warni NGTesting the All-Clear Photosystem Security Switch is GarageOperator Wiring Diagram Wiring Auxiliary Equipment Series Connection Receiver FirstInstallation Checklist Troubleshooting Guide Symptom Probable CAUSE/SOLUTIONSolution Probable CauseAllstar Corporation Downingtown, PA