Manitowoc Ice S1000M Water Trough, Water Distribution Tube Removal, Section, Maintenance

Page 29

Section 4	Maintenance

3. Water Distribution Tube

!Warning

Removing the distribution tube while the water pump is running will allow water to spray from ice machine. Disconnect the electrical power to the ice machine and dispenser at the electric service switch box and turn off the water supply.

NOTE: Distribution tube thumbscrews are retained by o- rings to prevent loss. Loosen thumbscrews but do not pull thumbscrews out of distribution tube.

4.Water Trough

A.Depress tabs on right and left side of the water trough.

B.Allow front of water trough to drop as you pull forward to disengage the rear pins.

DEPRESS TABS

Water Distribution Tube Removal

A.Remove outer half of distribution tube by loosening the four (4) thumbscrews (o-rings retain thumbscrews to distribution tube).

B.Pull inner half of water distribution tube forward to release slip joint from water pump tubing connection.

Part Number 80-1561-3

4-7

Image 29

Contents S1000M Model Ice Machines Installation Use and Care ManualPERSONAL INJURY POTENTIAL Read These Before ProceedingSafety Notices Procedural NoticesSection Installation Instructions Table of Contents continued Section General InformationManitowoc Cleaner and Sanitizer AuCS Automatic Cleaning SystemSection Maintenance Table of Contents continued Section Ice Machine OperationSection Before Calling For Service Guardian Sachet Replacement FrequencySection General Information How to Read a Model NumberSection General InformationMANITOWOC CLEANER AND SANITIZER AccessoriesAUCS AUTOMATIC CLEANING SYSTEM BIN CASTERMODEL/SERIAL PLATE LOCATION Model/Serial Number LocationModel/Serial Number Location Warranty Coverage Owner Warranty Registration CardAUTHORIZED WARRANTY SERVICE Service CallsInstallation Instructions Section Installation InstructionsIce Machine Dimensions Width, Depth, and Height DimensionsThe location must be free of airborne and other contaminants Location of Ice MachineIce Machine Heat of Rejection VOLTAGE Electrical ServiceFUSE/CIRCUIT BREAKER MINIMUM CIRCUIT AMPACITYFor United Kingdom Only Self-Contained Electrical Wiring ConnectionsSELF CONTAINED ICE MACHINE 115/1/60 OR 208-230/1/60 SELF CONTAINED ICE MACHINE 208-230/3/60Cooling Tower Applications Water-Cooled Models Water Supply and Drain RequirementsWATER SUPPLY AIR GAPPlumbing must conform to state and local codes Typical Water Supply Drain InstallationWATER SUPPLY AND DRAIN LINE SIZING/CONNECTIONS Is the Ice Machine level? Installation Check ListPotential Personal Injury Situation Before Starting the Ice MachineIce Machine Operation Section Ice Machine OperationComponent Identification sv3149INITIAL START-UP OR START-UP AFTER AUTOMATIC SHUT-OFF 1. Water Purge Sequence Of Operation2. Refrigeration System Start-Up FREEZE SEQUENCE 3. PrechillHARVEST SEQUENCE 5. Water Purge SAFETY TIMERS6. Harvest AUTOMATIC SHUT-OFF 7. Automatic Shut-OffWATER LEVEL Operational ChecksICE THICKNESS CHECK Ice Thickness Check45 second setting 0 second setting Water Purge AdjustmentHARVEST SEQUENCE WATER PURGE THIS PAGE INTENTIONALLY LEFT BLANK Maintenance Section MaintenanceExterior Cleaning Ice Machine InspectionGuardian Location GUARDIAN SACHET REPLACEMENT FREQUENCY SACHET INSTALLATION/REPLACEMENT PROCEDURECLEAN UP PROCEDURE FOR DAMAGED SACHET PACKET GuardianStep Interior Cleaning and SanitizingCLEANING PROCEDURE Remove all ice from the bin SANITIZING PROCEDURERefer to Removal of Parts For Cleaning Cleaner REMOVAL OF PARTS FOR CLEANING/SANITIZING16 oz 500 ml cleaner 1 gal. 4 lWater Curtain Removal 1. Water Curtain2. Ice Thickness Probe Ice Thickness Probe RemovalWater Distribution Tube Removal 3. Water Distribution Tube4. Water Trough Water Pump Removal Water Level ProbeWater Pump Water Dump Valve Dump Valve DisassemblyPLUNGER SPRING STOP COIL SPRINGDrain Line Check Valve 4-10Evaporator Tray Removal 4-11 Removing the Front PanelWater Inlet Valve Panel RemovalPry Open the Water Regulating Valve AUCS→ Accessory Removal from Service/Winterization4-12 SELF-CONTAINED WATER-COOLED ICE MACHINESBefore Calling For Service Section Before Calling For ServiceChecklist ProblemCall for service Safety Limit FeaturePage 2004 Manitowoc Ice, Inc. Litho in U.S.A MANITOWOC ICE, INC