Samsung RS2666 Evaporator in Freezer, Freezer Thermistor, Ambient Thermistor, Ice-MakerThermistor

Page 21

Mechanical Disassembly

Evaporator in Freezer

Evaporator is located in the bottom of freezer to produce cold air driven across the evaporator coils.

1.Take off the ductwork in Freezer.

2.Disconnect the wire connector (Heater, Bimental, and Thermistor).

3.Desolder the inlet and outlet tubes.

4.Remove the evaporator.

5.Take the same steps to seal the system as mentioned earlier.

Accumulator

Bimetal

Thermal

Fuse

Thermistor

Freezer Thermistor

The freezer thermistor is located at the top left of freezer vent. It sends temperature signals to the micro-processor.

Freezer Thermistor

Ambient Thermistor

The ambient thermistor is located inside the upper hinge cover. It sends temperature signals to the micro-processor.

Ambient

Thermistor

Ice-MakerThermistor

The Ice-Maker thermistor is located in its bottom. The temperature signal sends the micro-processor.

Thermistor(Ice-Maker)

Image 21

Contents Model RS2544 RS2622 RS2644 RS2666 RS2777 Important Safety Notice Contents Multi-Flow System Door AlarmXtra SpaceTM Xtra FreshTMTo protect refrigerator in movement Cover using a screwdriver, and then disconnectWith the door closed, remove the upper hinge It does not fall on youModels NomenclatureCompany Name Product R Refrigerator Label LocationFreezer Refrigerator SpecificationsWarranty information Shelves and Bins Interior Views and DimensionsFreezer RefrigeratorDimensions of Refrigerator Inches Refrigerant Route in Refrigeration cycle Refrigeration Cycle and Cool Air Circulation RouteFreezer Evaporator Dryer Capillary TubeCool Air Circulation Freezer Refrigerator Refrigerator Disassembly Mechanical DisassemblyFreezer Disassembly PlasticWire Drawer in Freezer······························Door Handle Control PanelBeverage StationTM Door GasketRefrigerator Light Refrigerator Door Light SwitchTempered Glass Shelf Plastic Drawers in RefrigeratorUpper Ductwork Water FilterEvaporator Cover in the Refrigerator Evaporator Fan MotorRefrigerator Thermistor Evaporator in RefrigeratorCoolSelect ZoneTM Thermistor CoolSelect ZoneTM ThermistorPlastic Wire Drawer in Freezer Freezer Door Light SwitchDoor Bin in Freezer Freezer ShelfDisconnect the ice maker wire connector Ice maker is located inside of the ice dispenser assemblyAuger Motor Case Unlock the locking tabs to separate the ice maker kitEvaporator Cover in Freezer Freezer LightFreezer Thermistor Evaporator in FreezerAmbient Thermistor Ice-MakerThermistorWater Solenoids Machine Compartment ＆ Electric BoxCondenser Fan Sub-condenserOperation Function Digital Panel Temperature Control FunctionQuick Ice and Power Cool Functions Power FreezeQuick Ice functionChild Lock Function Fan Motor Delay Function of the Machine Compartment Ice & Water Dispenser FunctionCoolSelect ZoneTM Function RS2666,RS2777 Water Filter Indicator Function Filter IndicatorIce-Maker Function Initial Operation function Preparation of Ice-makerJudgement Remark ·MICOM PortDefrost Function Water Supply functionHeater on Heater OFFDefrost operation Self-Diagnostics Function Beeps will cease immediately when the doors are closedSelf-Diagnostics in the initial Power on Sound FunctionError items of self-diagnostics ErrorFunction error Error items LED Display Details RemarksThis mode, only the display LEDs for temperature will be on Restoration Function for Power OutageLoad Operation Check Function Set Point Shift FunctionTable of Set Point Shift Function Shift the freezer temperature sensorOperation Function Shift the Ice maker temperature sensor Shift the CoolSelect ZoneTM temperature sensorCircuit Descriptions Reset Circuit Source Power CircuitOscillator Circuit TerminalDoor S/W Sensing Circuit Temperature Sensing CircuitMicom ChangeDEF-sensor and Bimetal work in parallel Key Scan and Display CircuitKey Scan and display operation Key Scan CoolSelect ZoneTM Panel Circuit Fan Motor Bldc Drive Circuit Motor drive circuitVoltages between high-speed and low-speed Option Circuit Eeprom CircuitLoad Drive Circuit D602COMP. equivalence circuit of drive section If power is not on DiagnosticsStart NormalIf the compressor and cooling fan motor don’t work normally AssemblyCheck after a lapse of 5 min ConnectionIf defrost function Exchange and troubleshoot Corresponding sensorPerform forced defrosting for F Room at a time If there is a trouble with self-diagnosis If the temperature sensor of F and R room has troubleIf the ambient sensor has trouble Start Check if the iced solder of main PCB is ShortIf Ding-Dong sounds continuously Start If alarm soundIf Beep sounds continuously Start Remove causes afterWithout sound of buzzer operation Start Main PCB is normal buzzer normalDisplay’ ZoneTM panel If the panel PCB is not working normallyConnections of door S/W If fan doesn’t work ReferenceDoor open DC Door closeIf the lamp of CoolSelect ZoneTM is not lit Start If CoolSelect ZoneTM isn’t operated normally RS2555, RS2577If the Panel PCB key isn’t selected Panel PCB has trouble for itselfIs the inside lamp filament cut? If the lamps of freezer / refrigerator does not lightCheck the operation of SSR71 and Q701 If Crushed Ice/Cubed Ice doesn’t work properly Safety Instructions on Service DC 0V Stop Condition Appendix ⅠReference for circuit diagnosticsResistance value ∼DC 12V load working conditionValue Contents For safety, you must turn the power off LoadRef Check a load Ref. Def heaterLamp Lamp on the REF Ref Check Door S/W834 878791 749Part Name Specifcation ’TY Ref Service part lists of each circuit boardPage Page Refrigerator Division 2003 Code DA82-00001D Electronics