OPERATING INSTRUCTIONS
GENERAL GLASS INFORMATION |
|
| GLASS |
| |||
|
|
| FRAME |
FIREPLACE
Only glass approved for use in Majestic products may be used for replacement.
FRONT
1 . The use of subsitute glass will void all product warranties.
CLAMPS
2.Care must be taken to avoid breakage of the glass.
3.Under no circumstances should this appliance be operated without the glass front or with a broken glass
front. Replacement of the glass | (with gasket) as | WINDOW |
|
FRAME |
| ||
supplied by the manufacturer should be done by a |
|
| |
licenced qualified service person. | WINDOW |
|
|
FRAME | PULL |
| |
| PUSH | CLAMP HOOK |
|
| CLAMP HANDLE | Fig. 64 | |
|
|
|
|
|
| LOUVRE REMOVAL |
|
|
|
| ||||||||||||||
|
|
|
|
| FRONT GLASS REMOVAL |
| |||||||||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| |
(Fig. 63) To remove top louvre pull louvre up and then |
|
|
|
| |||||||||||||||||
|
|
|
| ||||||||||||||||||
lift out. |
|
| ONLY FOR SERVICE - TO CLEAN THE | ||||||||||||||||||
|
|
| 2. |
|
|
|
|
|
|
|
|
|
|
|
| GLASS THERE IS NO NEED TO REMOVE IT. | |||||
|
|
|
|
|
|
|
|
|
|
|
|
| 1 | Shut off gas. | |||||||
|
|
|
|
|
|
|
|
|
|
|
|
| |||||||||
|
|
|
|
|
|
|
|
|
|
|
|
| |||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| ||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| LOUVRE |
| 2. | Let the fireplace cool if it has been operating. | ||
|
|
| 1. |
|
|
|
|
|
|
|
|
|
|
|
|
| 3. | Remove side glass (See Side Glass Removal). | |||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| 4. | Remove logs | ||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| 5. | Remove bottom refractory. | ||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| (CAUTION - LOGS AND REFRACTORY COULD BE HOT). | ||
|
|
|
|
|
|
|
|
|
|
|
|
|
| GLASS |
| 6. | Remove plate cover. | ||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| 7. | Remove grate assembly. | |||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| |||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
| PANEL Fig. 63 |
| 8. | Remove two burner assemblies and log support. | ||||
|
|
|
|
|
|
|
|
|
|
|
| ||||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| 9. | Remove front upper and lower window brass by | ||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| pulling off frame. | |
|
|
| SIDE GLASS REMOVAL |
|
| ||||||||||||||||
|
|
| 10. | Undo 10/24 nuts located on side trim mounting | |||||||||||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| frame. Remove trim frame. | |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| ||
1. | Shut off gas. | 11. | Push from front side of glass bottom into fireplace | ||||||||||||||||||
2. | Let the fireplace cool if it has been operating. |
|
| while holding glass from inside fireplace till screw | |||||||||||||||||
3. | Remove side top louvre. (See Louvre Removal) |
|
| studs are out of trim frame. | |||||||||||||||||
4. | Open the side lower louvre assembly. | 12. | Lift out glass front. | ||||||||||||||||||
5. | Release the two clamps at the bottom of the window | 13. | To reinstall glass follow the above procedure in | ||||||||||||||||||
|
| frame by pulling down on the clamp handles. |
|
| reverse. (Fig. 65) | ||||||||||||||||
6. | Lift off the glass frame as shown. |
|
|
|
| ||||||||||||||||
|
|
|
| ||||||||||||||||||
7. | To reinstall glass follow the above procedure in |
|
|
|
| ||||||||||||||||
|
| reverse. (Fig. 64) |
|
|
|
|
Fig. 65
- 27 -