Southbend Marathoner manual Operation, LIGHTING, RELIGHTING, and Shutdown Instructions

Page 22

OPERATION

OPERATION

MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS

OPERATION

!DANGER

EXPLOSION HAZARD

In the event a gas odor is detected, shut down equipment at the main shut off valve. Immediately call the emergency phone number of your gas supplier.

!CAUTION

To eliminate gas build up which could result in an explosion, in the event of main burner ignition failure a five minute purge period must be observed prior to re-establishing ignition source.

NOTICE

For an appliance equipped with a convection oven, no attempt should be made to operate oven during a power failure.

LIGHTING, RELIGHTING, AND SHUTDOWN INSTRUCTIONS

To light the oven, just switch the power switch at the top left corner of the control panel to the “ON” position. (The oven is equipped with a direct hot surface ignition system. There is no pilot to light.)

If the burners fail to ignite within four seconds, the oven will automatically shut off the gas, wait five minutes to allow the gas that was released to dissipate, and try to light the burners again. If the burners still fail to ignite after three such attempts, the oven will stop trying, even though the power switch is in the “ON” position. To continue to attempt to light the burners, turn the power switch “OFF” and then “ON” again.

To shutdown the oven, switch the power switch to the “OFF” position. For a complete shutdown, also open the control panel and turn the manual shut-off valve to the “OFF” position.

OPERATING THE CONTROLS

A convection oven is a different type of oven that offers many features and advantages to the food service operation. The additional capabilities and features of the oven require some learning. However, the operation of the oven is not difficult to understand or control once you have some practice.

The oven will have one of the four types of control panels:

•Models with Standard Controls are the most similar to a standard (non-convection) oven. Instructions for operating this type of oven begin on page 23.

•Models with Cycle/Cook and Hold Controls enable you to have the oven automatically enter a “hold mode” after a timed cooking period. Instructions for operating this type of oven begin on page 25.

•Models with Programmable Controls enable you to have the oven change temperature and other settings while cooking, then optionally enter a “hold mode.” You can record up to five “cook programs” which can then be re-used later. Instructions for operating this type of oven begin on page 28.

•Models with Rack Timer Controls provide five separate timers that independently time the cooking of food on each rack of the oven. The oven will tell you which rack will finish cooking next, and how much time remains. Instructions for operating this type of oven begin on page 31.

PAGE 22

OPERATOR’S MANUAL 1181887 REV 3

Page 21 Page 23
Image 22
Page 21 Page 23
Contents GAS Convection Ovens Safety Precautions Table of Contents Specifications Electricity SupplyGAS Supply Model Number # of Ovens Oven Depth Type of Gas Orifice SizeExterior Dimensions Single-Deck OvensTOP View Minimum Clearances VentilationInstallation UnpackingInstallation of Legs on Single-Deck Ovens Installation of Legs on Double-Deck Ovens Installation of Restraint Only for Ovens with Casters Stack Double-Deck Oven if necessary Operator ’S Manual 1181887 REV Elbow Install the flue stack as shown in the following diagram Install Down Draft Diverter if applicable Installation of Optional Open Rack Storage Operator ’S Manual 1181887 REV Connect Electricity Electric Grounding InstructionsCheck the Installation Connect Gas SupplyLIGHTING, RELIGHTING, and Shutdown Instructions OperationOperating the Controls Power Switch Control Panel of Standard ModelsTemperature of the oven Operation of Standard ModelsControl Panel of CYCLE/COOK and Hold Models Time DisplayOperation of CYCLE/COOK and Hold Models Operation Programs Indicators Control Panel of Programmable ModelsOperation of Models with Programmable Controls Operation Control Panel of Rack Timer Models Power Switch Time DisplayOperation of Rack Timer Models Overloading Time & TemperatureCooking Hints Helpful SuggestionsCooking Problems and Solutions Guide to Times and TemperaturesHints Daily Cleaning CleaningMonthly Cleaning SEMI-ANNUAL Cleaning Cleaning Stainless Steel SurfacesAdjusting GAS Pressure Regulator AdjustmentsLubrication Adjusting Door Chain Mechanism Adjusting Door SwitchTemperature Controller Standard-Control Models Only Fahrenheit or Celsius Display Cycle/Cook & Hold Models OnlyInterpreting Displayed Error Codes TroubleshootingPerformance Standard Troubleshooting Guide Table continues on nextTroubleshooting Guide Control Panel Access and SHUT-OFF SwitchBlower Wheel Replacement Troubleshooting Troubleshooting Troubleshooting Troubleshooting Troubleshooting Troubleshooting Index of Parts Diagrams PartsFront Panel and Flue Parts Door Parts Door Chain Mechanism Parts Marathoner Gold & Silverstar GAS Convection Ovens See parts list on previous 1920 Parts See parts list on previous 1918 Parts See parts list on previous Parts Parts Internal Gas Supply Parts Burner Compartment Parts Oven Interior and Fan Motor Parts Oven Light Parts Leg Parts for Single-Deck SilverStar Models Leg Parts for Single-Deck Marathoner Gold Models Storage Rack Parts Double-Deck Oven Stacking Parts Leg Parts for Double-Deck Ovens OPERATOR’S Manual 1181887 REV Marathoner Gold & Silverstar GAS Convection Ovens Marathoner Gold & Silverstar GAS Convection Ovens Marathoner Gold & Silverstar GAS Convection Ovens GAS Convection Ovens

Marathoner specifications

The Southbend Marathoner is an innovative and highly efficient piece of equipment designed for both amateur runners and seasoned athletes alike. This state-of-the-art treadmill combines advanced technology with a focus on performance, comfort, and durability, making it a popular choice for fitness enthusiasts. The Southbend Marathoner features an impressive motor that delivers a smooth, consistent performance, allowing users to reach their desired speed without interruption. With a peak horsepower that rivals that of commercial-grade treadmills, it is well-suited for rigorous training sessions.

One of the standout features of the Southbend Marathoner is its advanced cushioning system. This technology significantly reduces impact on joints, promoting a more comfortable running experience and minimizing the risk of injury. The cushioned running surface is designed to replicate outdoor conditions, providing an authentic feel that simulates the experience of running on natural terrain.

The treadmill comes equipped with a large, user-friendly display that provides essential metrics including speed, distance, time, calories burned, and heart rate. This data is crucial for runners looking to monitor their progress and set new personal records. Furthermore, the Southbend Marathoner includes Bluetooth connectivity, allowing users to sync their fitness trackers and access detailed performance analytics through compatible apps.

Another notable characteristic is the treadmill's incline feature, which can be adjusted electronically to replicate hill running. This added level of intensity allows users to diversify their workouts and enhance their endurance over time. With a maximum incline of 15%, runners can simulate challenging terrains, improving strength and stamina.

In addition to its impressive performance features, the Southbend Marathoner boasts a sleek and modern design. The treadmill is built with high-quality materials that ensure longevity and stability during use. Its foldable design offers practical storage solutions for smaller spaces, making it a versatile option for home gyms.

In summary, the Southbend Marathoner stands out as a premier treadmill that caters to the needs of runners at every skill level. With its powerful motor, advanced cushioning system, user-friendly display, connectivity options, and adjustable incline settings, it provides a comprehensive and enjoyable running experience. It's more than just a treadmill; it's an investment in fitness that supports and motivates users to achieve their running goals.
Top Page Image Contents