Southbend Marathoner manual Daily Cleaning, Monthly Cleaning

Page 36

CLEANING

CLEANING

MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS

CLEANING

Southbend equipment is sturdily constructed of the best materials and is designed to provide durable service when treated with ordinary care. To expect the best performance, your equipment must be maintained in good condition and cleaned daily. Naturally, the periods for this care and cleaning depend on the amount and degree of usage.

Following daily and periodic maintenance procedures will enhance long life for your equipment. Climatic conditions (such as salt air) may require more thorough and frequent cleaning or the life of the equipment could be adversely affected.

The oven interior is finished with a porcelain enamel coating. “Spillovers” should be cleaned from the interior bottom surface as soon as possible to prevent carbonizing and a burnt-on condition. Grease or any residue should be cleaned from interior surfaces as soon as it accumulates.

!WARNING

FOR YOUR SAFETY, DISCONNECT THE POWER SUPPLY TO THE APPLIANCE BEFORE CLEANING.

WHEN CLEANING THE BLOWER WHEEL, BE SURE TO HAVE THE POWER SWITCH IN THE “OFF” POSITION.

DAILY CLEANING

1.Turn the power switch to OFF and allow the oven to cool.

2.Remove the oven-interior racks and rack slide frames. (The rack slide frames are readily removable by merely raising to disengage them from their sockets.) Wash the racks and rack slides in a sink with mild detergent and warm water. Dry them thoroughly with a clean cloth.

3.Look to see if any foreign matter has accumulated on the blades of the blower wheel (which will reduce air circulation). If necessary, remove the rear lining of the oven, which is secured by thumbscrews near each corner. Use a stiff brush to remove accumulations from the blower blades, then wash with soap and water.

4.Wash the interior surfaces with mild detergent and warm water. Rinse with clean water, and dry thoroughly with a clean cloth. For stubborn accumulations, a commercial oven cleaner may be used.

5.Clean the control panel with warm water and mild soap. Never use cleaning solvents with a hydrocarbon base.

6.Wipe the other exterior surfaces with a clean damp cloth. If the exterior surfaces require more thorough cleaning, see “Cleaning Stainless Steel Surfaces” on the next page.

7.Return the rack slides and racks to their appropriate locations inside the oven.

8.LEAVE THE DOOR OPEN AT NIGHT AFTER CLEANING. This allows the oven to dry thoroughly after cleaning and also prolongs the life of the door gasket.

MONTHLY CLEANING

Clean around rear of motor (where the vent screen is located), louvered panels, and primary air holes in the rear of the oven where grease or lint may have accumulated.

PAGE 36

OPERATOR’S MANUAL 1181887 REV 3

Page 35 Page 37
Image 36
Page 35 Page 37
Contents GAS Convection Ovens Safety Precautions Table of Contents Specifications Electricity SupplyGAS Supply Model Number # of Ovens Oven Depth Type of Gas Orifice SizeExterior Dimensions Single-Deck OvensTOP View Minimum Clearances VentilationInstallation UnpackingInstallation of Legs on Single-Deck Ovens Installation of Legs on Double-Deck Ovens Installation of Restraint Only for Ovens with Casters Stack Double-Deck Oven if necessary Operator ’S Manual 1181887 REV Elbow Install the flue stack as shown in the following diagram Install Down Draft Diverter if applicable Installation of Optional Open Rack Storage Operator ’S Manual 1181887 REV Connect Electricity Electric Grounding InstructionsCheck the Installation Connect Gas SupplyOperation LIGHTING, RELIGHTING, and Shutdown InstructionsOperating the Controls Power Switch Control Panel of Standard ModelsTemperature of the oven Operation of Standard ModelsControl Panel of CYCLE/COOK and Hold Models Time DisplayOperation of CYCLE/COOK and Hold Models Operation Programs Indicators Control Panel of Programmable ModelsOperation of Models with Programmable Controls Operation Control Panel of Rack Timer Models Power Switch Time DisplayOperation of Rack Timer Models Time & Temperature Cooking HintsOverloading Helpful SuggestionsCooking Problems and Solutions Guide to Times and TemperaturesHints Cleaning Daily CleaningMonthly Cleaning SEMI-ANNUAL Cleaning Cleaning Stainless Steel SurfacesAdjustments Adjusting GAS Pressure RegulatorLubrication Adjusting Door Chain Mechanism Adjusting Door SwitchTemperature Controller Standard-Control Models Only Fahrenheit or Celsius Display Cycle/Cook & Hold Models OnlyTroubleshooting Interpreting Displayed Error CodesPerformance Standard Troubleshooting Guide Table continues on nextTroubleshooting Guide Control Panel Access and SHUT-OFF SwitchBlower Wheel Replacement Troubleshooting Troubleshooting Troubleshooting Troubleshooting Troubleshooting Troubleshooting Index of Parts Diagrams PartsFront Panel and Flue Parts Door Parts Door Chain Mechanism Parts Marathoner Gold & Silverstar GAS Convection Ovens See parts list on previous 1920 Parts See parts list on previous 1918 Parts See parts list on previous Parts Parts Internal Gas Supply Parts Burner Compartment Parts Oven Interior and Fan Motor Parts Oven Light Parts Leg Parts for Single-Deck SilverStar Models Leg Parts for Single-Deck Marathoner Gold Models Storage Rack Parts Double-Deck Oven Stacking Parts Leg Parts for Double-Deck Ovens OPERATOR’S Manual 1181887 REV Marathoner Gold & Silverstar GAS Convection Ovens Marathoner Gold & Silverstar GAS Convection Ovens Marathoner Gold & Silverstar GAS Convection Ovens GAS Convection Ovens

Marathoner specifications

The Southbend Marathoner is an innovative and highly efficient piece of equipment designed for both amateur runners and seasoned athletes alike. This state-of-the-art treadmill combines advanced technology with a focus on performance, comfort, and durability, making it a popular choice for fitness enthusiasts. The Southbend Marathoner features an impressive motor that delivers a smooth, consistent performance, allowing users to reach their desired speed without interruption. With a peak horsepower that rivals that of commercial-grade treadmills, it is well-suited for rigorous training sessions.

One of the standout features of the Southbend Marathoner is its advanced cushioning system. This technology significantly reduces impact on joints, promoting a more comfortable running experience and minimizing the risk of injury. The cushioned running surface is designed to replicate outdoor conditions, providing an authentic feel that simulates the experience of running on natural terrain.

The treadmill comes equipped with a large, user-friendly display that provides essential metrics including speed, distance, time, calories burned, and heart rate. This data is crucial for runners looking to monitor their progress and set new personal records. Furthermore, the Southbend Marathoner includes Bluetooth connectivity, allowing users to sync their fitness trackers and access detailed performance analytics through compatible apps.

Another notable characteristic is the treadmill's incline feature, which can be adjusted electronically to replicate hill running. This added level of intensity allows users to diversify their workouts and enhance their endurance over time. With a maximum incline of 15%, runners can simulate challenging terrains, improving strength and stamina.

In addition to its impressive performance features, the Southbend Marathoner boasts a sleek and modern design. The treadmill is built with high-quality materials that ensure longevity and stability during use. Its foldable design offers practical storage solutions for smaller spaces, making it a versatile option for home gyms.

In summary, the Southbend Marathoner stands out as a premier treadmill that caters to the needs of runners at every skill level. With its powerful motor, advanced cushioning system, user-friendly display, connectivity options, and adjustable incline settings, it provides a comprehensive and enjoyable running experience. It's more than just a treadmill; it's an investment in fitness that supports and motivates users to achieve their running goals.
Top Page Image Contents