CLEAN AIR FILTER
A dirty air filter decreases engine per- formance and increases fuel consump- tion and harmful emissions. Always clean after every 5 hours of operation.
Button _\
Air Filter \_"
Air Filter Cover _'_ |
Fuel Filter
\
Fuel Line
CHECK MUFFLER MOUNTING SCREWS
Once each year, ensure muffler mounting screws are secure and tight- ened properly to prevent damage.
Cleaning the air filter:
1.Clean the cover and the area
around it to keep debris from falling into the carburetor chamber when the cover is removed.
NOTE: Move start lever to RUN posi- tion before opening air filter cover.
2.Open air filter cover by pushing button (see illustration). Remove air filter.
NOTE: Do not clean filter in gasoline or other flammable solvent. Doing so can create a fire hazard or produce harmful evaporative emissions.
3.Wash the filter in soap and water.
4.Allow filter to dry.
5.Apply a few drops of oil to the filter; squeeze filter to distribute oil.
6.Replace parts.
REPLACE SPARK PLUG
Replace spark plug each year to ensure the engine starts easier and runs better. Set spark plug gap at 0.025 inch. Igni- tion timing is fixed, nonadjustable.
1.Twist, then pull off spark plug boot.
2.Remove spark plug from cylinder and discard.
3.Replace with Champion
4.Reinstall the spark plug boot.
REPLACE FUEL FILTER
To replace fuel filter, drain unit by run- ning it dry of fuel, then remove fuel cap/retainer assembly from tank. Pull filter from tank and remove it from the fuel line. Install new fuel filter on fuel line; reinstall parts.
'/
Mounting Screw
INSPECT MUFFLER AND SPARK
ARRESTING SCREEN
_WARNING: | The muffler on this |
product contains chemicals known to the State of California to cause cancer.
As the unit is used, carbon deposits build up on the muffler and spark ar- resting screen, and must be removed to avoid creating a fire hazard or af- fecting engine performance.
Muffler Cover
Spark
Arresting
Hood
r
Screws
Replace the spark arresting screen ev- ery 50 hours of operation or if any dam- age or breaks in the screen are noted.
NOTE: Do not attempt to clean the spark arresting screen.