Summit 3522a manual Safety Notices

Page 5

1 SAFETY

Familiarity with all equipment and proper training are required for the safe operation of any mechanical device. Attempting to operate any mechanical equipment improperly or without training creates a situation that is potentially hazardous. Prior to operation, read the instructions and safety precautions included in this manual and attached to the lift. Become familiar with the proper use of all controls. Inexperienced operators should receive instruction before attempting to operate or maintain the machine.

Always follow the safety procedures set forth in this manual as well as all applicable ANSI, OSHA, state and local regulations. Persons under the influence of drugs, alcohol or prescription medications should not be allowed on or near this equipment. Do not operate in areas where the machine or its operator may come into contact with a live power source.

The information contained herein is provided to alert Bil-Jax customers to the normal procedures for the operation and maintenance of the Bil-Jax Model 3522A Articulating Boom Lift. This information is not intended to be all-inclusive, nor is it to be considered legal advice. These procedures are to be followed in the care and maintenance of the named Bil-Jax equipment only.

For any questions concerning the safe use of this equipment, contact the Bil-Jax Service Department at 800-537-0540 before attempting operation.

The use of intelligence and common sense is the best practice in following any safety policy.

SAFETY NOTICES

This manual contains a variety of notices that must be observed to prevent the possibility of improper service, personnel injury or death, or damage to the equipment.

DANGER

Warns of operation near electrical power sources that could lead to personal injury or death.

WARNING

Describes conditions or practices that could lead to personal injury or death.

CAUTION

Contains information important in the prevention of errors that could damage machine or components.

NOTE: Contains additional information important for performing a procedure.

3

Page 4 Page 6
Image 5
Page 4 Page 6
Contents Page Taylor Parkway Archbold, Ohio Phone800 419 Fax 419 Boom Personnel Lift Copyright Bil-Jax, Inc . All Rights Reserved Table of Contents List of Tables List of IllustrationsSafety Notices SafetyDuring Operation Before OperationGeneral Maintenance Maintenance SafetyBattery Maintenance Damaged Equipment Policy Safety StatementNhtsa Reporting Safety DefectsModel 3522A Articulating Boom Lift General IntroductionBoom Lift Control Panel Ground Feature Model 3522A SpecificationsWarranty Claims Process WarrantyOperation Ground Control Station Ground Control StationDisplay Panel Platform Control Station Platform Control StationVolt Outlet Outrigger Controls Normal Operating ProcedureOperation Hand Pump and Controls for Manual Lift Operation Manual Boom OperationManual Lowering Battery Charger Faceplate Battery RechargeTrailer Hitching Boom Lift TransportBIL-JAX 3522A Operator Service Verify that boom down limit switches operate correctly Daily Service ChecksVerify that outrigger safety interlocks operate correctly Verify correct tire inflationMonthly Service Checks Weekly Service ChecksCheck Battery electrolyte level Inspect all electrical wiringTroubleshooting Steps TroubleshootingError Code Definitions Error Code DefinitionsError Message Definition of Error Comments LR Outrigger BIL-JAX 3522A Identification Plates Replacement DecalsDecal Locations Ansi Reprint Responsibilities of Dealers and InstallersInspection and Test Records Responsibility of Users Responsibilities of Renters, Lessors or Lessees Denotes Prohibited Zone BIL-JAX 3522A Material Safety Data Sheet Material Safety DataSection V -- Health Hazard Data Section II -- Health Hazard Data BIL-JAX 3522A Equipment Options Material Lifting Hook Material Lifting Hook ConfigurationPlatform Rotator Horizontal JIB RotatorCombination Hitch Combination Hitch InstallationReplacement Decals Decal No Description of Decal Replacement DecalsPage BIL-JAX Model 3522A Quick Start Guide Taylor Parkway Archbold, OH Phone 419 800 Fax
Top Page Image Contents