Summit 3522a manual Battery Maintenance

Page 8

BIL-JAX 3522A

NEVER adjust, repair, replace or bypass any hydraulic or electrical control or safety device. These include, but are not limited to, hydraulic load control and flow control valves, solenoid valves and limit switches. Contact the Bil-Jax Service Department at 800-537-0540 if these components require maintenance.

NEVER attempt repairs or maintenance without first consulting manufacturer regarding proper procedures.

Battery Maintenance

Ensure the following general safety precautions are followed whenever performing battery maintenance on the Bil-Jax Model 3522A Articulating Boom Lift:

ALWAYS check battery acid level daily.

ALWAYS wear safety glasses when working with or near batteries.

ALWAYS avoid contact with battery acid. Battery acid causes serious burns and should be kept away from skin and eyes. If contact occurs, flush with water and consult a physician immediately.

ALWAYS disconnect ground cable first when removing battery.

ALWAYS connect ground cable last when installing battery.

ALWAYS charge batteries in open, well-ventilated areas.

NEVER smoke while servicing battery.

NEVER charge batteries near flammable materials. NEVER allow batteries to overcharge and boil.

NEVER short across battery posts to check for current. NEVER break a live circuit at the battery.

NEVER disconnect battery from charger while charger is connected to a live power source.

NEVER jumpstart other vehicles using boom lift battery.

6

Image 8

Contents Page Taylor Parkway Archbold, Ohio Phone800 419 Fax 419 Boom Personnel LiftCopyright Bil-Jax, Inc . All Rights Reserved Table of Contents List of Illustrations List of TablesSafety Safety NoticesBefore Operation During OperationMaintenance Safety General MaintenanceBattery Maintenance Safety Statement Damaged Equipment PolicyReporting Safety Defects NhtsaGeneral Introduction Model 3522A Articulating Boom LiftBoom Lift Control Panel Ground Specifications Feature Model 3522AWarranty Warranty Claims ProcessOperation Ground Control Station Ground Control StationDisplay Panel Platform Control Station Platform Control StationVolt Outlet Normal Operating Procedure Outrigger ControlsOperation Manual Boom Operation Hand Pump and Controls for Manual Lift OperationManual Lowering Battery Recharge Battery Charger FaceplateBoom Lift Transport Trailer HitchingBIL-JAX 3522A Operator Service Daily Service Checks Verify that boom down limit switches operate correctlyVerify that outrigger safety interlocks operate correctly Verify correct tire inflationWeekly Service Checks Monthly Service ChecksCheck Battery electrolyte level Inspect all electrical wiringTroubleshooting Troubleshooting StepsError Code Definitions Error Code DefinitionsError Message Definition of Error Comments LR Outrigger BIL-JAX 3522A Replacement Decals Identification PlatesDecal Locations Responsibilities of Dealers and Installers Ansi ReprintInspection and Test Records Responsibility of Users Responsibilities of Renters, Lessors or Lessees Denotes Prohibited Zone BIL-JAX 3522A Material Safety Data Material Safety Data SheetSection V -- Health Hazard Data Section II -- Health Hazard Data BIL-JAX 3522A Equipment Options Material Lifting Hook Configuration Material Lifting HookHorizontal JIB Rotator Platform RotatorCombination Hitch Installation Combination HitchReplacement Decals Replacement Decals Decal No Description of DecalPage BIL-JAX Model 3522A Quick Start Guide Taylor Parkway Archbold, OH Phone 419 800 Fax