Maintenance
If the engine is operating in very dusty or dry grass conditions, a clogged air cleaner will result.This can lead to a loss of power, excessive carbon buildup in the combustion chamber and high fuel consumption. Change air cleaner more frequently if these conditions exists.
Fuel Addition
Add diesel fuel (the grade may vary according to season and locations).
Removing Water from the Fuel Tank
After prolonged use, water and other impurities accumulate in the bottom of the tank. Occasionally inspect the fuel tank for water contamination and drain the contents if required.
During cold weather, the more empty volume inside the tank, the easier it is for water to condense. This can be reduced by keeping the tank full with diesel fuel.
Cleaning Inside the Fuel Tank
If necessary, drain the fuel inside the fuel tank completely. Using a spray washer (Figure 54) wash out any deposits or debris that have accumulated inside the fuel tank.
Figure 54. Fuel Tank Cleaning
Fuel Tank Inspection
In addition to cleaning the fuel tank, the following components should be inspected for wear:
Rubber Suspension — look for signs of wear or deformity due to contact with oil. Replace the rubber suspension if necessary.
Fuel Hoses — inspect nylon and rubber hoses for signs of wear, deterioration and hardening.
FuelTank Lining — inspect the fuel tank lining for signs of excessive amounts of oil or other foreign matter.
Replacing Fuel Filter
Replace the fuel filter cartridge with new one every 500 hours or so.
Loosen the drain plug at the lower top of the fuel filter. Drain the fuel in the fuel body together with the mixed water. DO NOT spill the fuel during disassembly.
Vent any air
Fuel filter/water separator
Inspect the fuel filter water separator daily. If the fuel filter/ water separator (Figure 55) has collected a significant amount of water and sediment at the bottom of the cup, it should be drained off. Refer to your engine manual for specific details to perform this operation.
FUEL
COCK
RETAINING
RINGCUP
SEDIMENT
Figure 55. Fuel Filter/Water Separator
page 36 — DCA40sskU/ku4i 60 hz Generator • operation and parts manual — rev. #1 (03/11/13)