Land Pride 4400ex manual Driving Conditions

Page 19

Table of Contents

Section 4: Operating Instructions

Steering

Refer to Figure 4-5

Steering: The vehicle steers by pivoting about the center

swivel yoke with the aid of a hydraulic cylinder.

IMPORTANT: Become familiar with the steering capabilities of the Gondo before putting the vehicle into service. Be certain to practice steering going forward and backing up as it has a different feel than normal front wheel steered vehicles.

Center Swivel

Yoke

Power Steering

Hydraulic Cylinder

21346

Figure 4-5

Driving Conditions

Terrains vary creating different driving situations. The following are circumstances you might encounter and suggestions on how to operate the Gondo safely. Always approach each new situation with extreme caution until you have become experienced in handling your vehicle.

We recommend for your safety and the safety of others that you allow only operators experienced in driving a standard transmission, understand all potential dangers of operating this vehicle, has studied this manual, viewed the video safety tape supplied with this vehicle and has received actual hands-on instructions from an experienced operator.

Sandy Terrain

Tires with high air pressure perform better in loose sand. Also, stay in low gear to avoid spinning the wheels. Always maintain vehicle control, don’t make sharp turns and avoid hard braking when possible.

Muddy Terrain

Better traction is achieved by accelerating the vehicle slowly to avoid spinning the wheels. Making sharp turns and hard braking can cause the vehicle to skid out of control. Let up on the accelerator pedal and stop when skidding out of control.

Clean off mud residue stuck to rotating drive shafts and to the tires as quickly as possible. Mud clinging to rotating parts causes and imbalance that can damage vehicle components. Also clean the brake drums of mud to reduce premature brake wear.

Watery Terrain

Always determine the depth of water before driving through it. Do not drive through water that is higher than the bottom of the floor board. Always enter the water slowly and continue traveling slowly through the water to minimize splashing. The vehicle could stall if the electrical system gets wet. Never allow water to get up around the engine. A wet engine is likely to stall or become damaged.

Test the brakes for stopping capabilities once through the water. Allow the brakes to dry before proceeding if braking capabilities are reduced. Brakes can be dried faster by driving the vehicle slowly on a level surface while applying light pressure to the brake pedal.

Snowy and icy Terrain

Like muddy terrain, accelerate the vehicle slowly to avoid spinning the wheels. Avoid making sharp turns and hard braking. Let up on the accelerator pedal and stop when skidding out of control. Always maintain a steady slow speed allowing time to slow down and stop. Remember slick surfaces require more time to slow down, make turns and stops.

Uneven Terrain

The Gondo’s center articulating steering enables the four driving wheels to maintain contact in various uneven terrain situations. Because of this, the vehicle is capable of maneuvering over rough surfaces, up and down steep inclines. Avoid operating on excessively steep hills and especially on hills that are steeper than 15 degrees.

Climbing Steep Hills

Always approach a steep hill straight on in 1st (low gear) to reduce engine strain and minimize stalling. Continue straight up the hill in low gear moving right or left only to go around obstacles. Do not attempt to turn the vehicle around during a steep climb. If the vehicle stalls or should you decide to stop the climb, place vehicle in reverse gear and back down the hill slowly and as straight as possible to a safe location. If needed, apply the brakes very lightly to assist slowing down vehicle’s descent. Hard braking can cause total loss of control and a rollover situation. Don’t depress the clutch while backing down except when bringing the vehicle to a complete stop.

Maximum traction and control is achieved while traveling up a steep incline in 1st gear at the lowest possible speed. Also traveling slowly allows more time to correct a dangerous situation.

6/30/05

4400EX Heavy Duty Off Road Utility Vehicle 720-051M 17

Page 18 Page 20
Image 19
Page 18 Page 20
Contents Gondo Table of Contents Using This Manual Safety FirstApplication Product Support Land Pride Service Department East North StreetOwner Assistance Serial Number PlateBefore Operating Safety SymbolBe Aware of Signal Words For Your ProtectionWear Protective Equipment Practice Safe MaintenanceTire Safety Prepare for EmergenciesSafe Operating Procedures Table of Contents 818-543C Safety Decals838-492C 838-629C 838-486C 838-490C 838-628C 838-444C Dealer Test Ride List Dealer Service and Inspection ListPre-Delivery Certificate Vehicle InformationCustomer Acceptance List Dealer Delivery To Customer ListPre-Start Check List Dashboard Switches and InstrumentsOperator Responsibilities General OperationFoot Operated Controls Hand Operated Controls Fuel IndicatorDriving Conditions Towing Without a Trailer Towing the GondoDescending Steep Hills Traverse Traveling on Steep HillsTraveling Tips From the Trail Masters Table of Contents Tires Gondo AccessoriesGondo Options Rear Cargo BoxPrepare Vehicle for Maintenance General MaintenanceTorque Values Electrical System Tire MaintenanceJacking the Vehicle Shock AbsorbersJump Starting the Battery BatteryPrepare Vehicle to Jump-Start Disconnecting Jumper Cables Connecting Jumper CablesFuel System Emptying the Fuel Tank Engine MaintenanceFuel Filter and Fuel Line Maintenance Filling the Fuel TankHigh Altitude Carburetor Kit Power Steering BeltEngine Air Filter Air Filter Maintenance SchedulePrecleaner Foam Element Precleaner Element 61 mm deep -083-02-SSpark Arrester Spark Arrester Maintenance ScheduleSpark Arrester Maintenance Procedure Replacement PartsMaintenance Schedule Engine Oil Level Check Engine Oil Maintenance ScheduleEngine Oil Engine Oil Type and Capacity6mo/100hrs Engine Oil and Filter ChangeDifferential Oil Change Differential Maintenance ScheduleDifferential Oil Type and Capacity Differential Oil Level CheckBrake Fluid Transmission FluidGrease Type Lubrication Steering & Cargo Lift Cylinder FluidRotating Bearing Surfaces Pillow Block BearingShort term storage 90 days or less Engine Preparation for StorageVehicle Storage Preparation Vehicle Removal From Storage PreparationRequired Tools and Materials IntroductionLight Scuff ScratchDeep Gouge 4400EX Series Specifications and CapacitiesBrakes don’t function Symptoms Probable Causes Suggested Remedies Battery is deadBattery will not charge up Brakes are sticking won’t releaseEngine runs unevenly Engine overheatsStarter cranks slowly Engine stops runningGear Shift is malfunctioning Park brake doesn’t workVehicle looses ground speed without Steering does not track correctlySteering play is excessive Vehicle speed does not reach 17 MPHIn-tpi Ft-lb Torque Values ChartTable of Contents Utility Vehicle Land Pride Limited WarrantyCorporate Office P.O. Box 5060 Salina, Kansas 67402-5060 USA

4400ex specifications

The Land Pride 4400EX is a versatile and robust implement that is designed for agricultural operations and landscaping tasks. This exceptional piece of equipment stands out for its functionality and durability, making it an ideal choice for both professional landscapers and property owners seeking high-performance tools for ground preparation and maintenance.

One of the most notable features of the Land Pride 4400EX is its heavy-duty construction. Built with a solid frame, it ensures stability and reliability even in the challenging conditions of rugged terrains. The implement is designed to handle various tasks such as grading, leveling, and creating smooth surfaces, establishing it as a go-to choice for diverse applications.

The 4400EX is equipped with advanced technologies that enhance its operational efficiency. The implement utilizes a precision-engineered quick-attach system, allowing users to swap out attachments quickly and without complications. This feature saves valuable time on the job site and increases overall productivity.

Another highlight is its adjustable blade depth, which provides users with the versatility to achieve the desired finish for different projects. Whether users are working in soft soil or hard packed areas, the Land Pride 4400EX can adapt to the task at hand, ensuring a professional-grade result every time.

The implement is also designed with user comfort in mind. It features ergonomic controls that are easy to access, allowing operators to navigate smoothly through tasks without experiencing fatigue. Additionally, the Land Pride 4400EX is compatible with a variety of tractors, making it a flexible addition to any farming or landscaping arsenal.

Maintenance of the 4400EX is straightforward due to its design, which minimizes wear and tear on components. Regular upkeep helps ensure longevity, allowing users to leverage this equipment for years to come.

In conclusion, the Land Pride 4400EX stands out for its exceptional construction, advanced features, and user-friendly design. Its versatility and robust performance make it an invaluable tool for anyone looking to enhance their productivity in agricultural and landscaping tasks. With a focus on reliability and efficiency, the 4400EX continues to be a favored choice among professionals and enthusiasts alike.
Top Page Image Contents