Manuals / Bakers Pride Oven / Kitchen Appliance / Oven

Bakers Pride Oven DRG-40 Automation and Control Solutions, Honeywell International Inc, M1V 4Z9

Models: DRG-40

1 40

Page 39

Automation and Control Solutions

Honeywell International Inc.	Honeywell Limited-Honeywell Limitée
1985 Douglas Drive North	35 Dynamic Drive
Golden Valley, MN 55422	Scarborough, Ontario
	M1V 4Z9

Printed in U.S.A. on recycled

69-1226—2 G.R. Rev. 11-99paper containing at least 10%www.honeywell.com post-consumer paper fibers.

Page 39

Image 39

Bakers Pride Oven DRG-40 Automation and Control Solutions, Honeywell International Inc, Douglas Drive North, Dynamic Drive

Contents

Serial Numbers 120170 and Higher Gas Rotisserie OvenFOR YOUR SAFETY Warranty InformationLIMITED ONE YEAR WARRANTY REPLACEMENT PARTSTable of Contents Table of ContentsGas Rotisserie Oven Table of ContentsIntroduction Safety PrecautionsSafety Signs and Messages IntroductionProtect Children Wear Safe Clothing Appropriate To Your JobBeware of High Voltage Keep this manual with the EquipmentUse Gas Safely-- Avoid Danger Keep Safety Labels Clean and in Good ConditionBe Prepared for Emergencies Know your responsibilities as an EmployerDo Not Smoke Near The Oven Gas Rotisserie OvenIntroduction Safety Labels Gas Rotisserie OvenIntroduction Introduction Gas Rotisserie OvenGas Rotisserie Oven Controls and IndicatorsOperation OperationFunction 9 LOWER FLAME ON/OFF Switch 10 PUSH TO RESET Switch11 WATER FILL Switch 12 ROTOR JOG Switch Item # Description 1 HEAT ON LED 2 TIME/TEMP DisplayStop Mode Controller OperationModes Ready ModeGas Rotisserie Oven Setting a ProgramProgramming Reviewing a ProgramOperation Power Failure During Cooking CycleCooking Gas Rotisserie OvenGas Rotisserie Oven Probe Thermocouple DiagnosticsOperation After Gas or Power Outage Normal ShutoffPreparation InstallationInstallation Inspection for Shipping DamageGas Rotisserie Oven Installation ProcedureLocation and Clearance InstallationGas Conversion Instructions InstallationGas Rotisserie Oven Maintenance MaintenanceScheduled Maintenance Oven CleaningMaintenance 2. Turn off all switches and controls and let the oven coolGas Rotisserie Oven Maintenance Gas Rotisserie OvenB C Place the rotor shaft in a large sink SPINNER HUB MaintenanceIf using a dual rotor shaft, loosen the center spinner hub CENTER Gas Rotisserie OvenMaintenance Gas Rotisserie OvenA B C Maintenance Gas Rotisserie OvenA B C Maintenance Gas Rotisserie OvenCOUNTERSUNK SIDE 9. Reassemble the oven Possible Solution TroubleshootingGas Rotisserie OvenMaintenance ProblemGas Rotisserie Oven Appendix AGas Control Valve Instructions Appendix AVR8105, VR8205, and VR8305 Direct Ignition Combination APPLICATIONINSTALLATION INSTRUCTIONS Gas ControlsVR8105, VR8205, AND VR8305 DIRECT IGNITION COMBINATION GAS CONTROLS SPECIFICATIONSPLANNING THE INSTALLATION Frequent CyclingHigh Humidity or Dripping Water INSTALLATIONWater or Steam Cleaning When Installing this Product…Bushings Install Adapters To ControlConvertible Pressure Regulators FlangesFig. 3. Sediment trap installation Install Piping to ControlInstall Control LocationOUTLET WiringVR8105, VR8205, AND VR8305 DIRECT IGNITION COMBINATION GAS CONTROLS Fig. 5. Proper use of wrench on gas control with and without flangesTurn On System Gas Control Knob SettingsSTARTUP AND CHECKOUT Perform Gas Leak TestTwo-Stage Q Models Check and Adjust Gas Input and Burner IgnitionStandard and Slow-Opening H, K and M Models Step-Opening P ModelsSetting Range Controls OnlyCheck Safety Lockout Slow-Opening Table 8. Pressure Regulator Specification Pressures in. wcTable 9. Pressure Regulator Specification Pressures kPa MAINTENANCESERVICE Check Safety Shutdown PerformanceTurning Off the Appliance INSTRUCTIONS TO THE HOME-OWNERIf Main Burner Does Not Come On With Call For Heat To Turn ON Appliance STOP Read the Warnings Above Before Proceeding35 Dynamic Drive Automation and Control SolutionsHoneywell International Inc 1985 Douglas Drive North

Automation and Control Solutions

Honeywell International Inc.

Honeywell Limited-Honeywell Limitée

1985 Douglas Drive North

35 Dynamic Drive

Golden Valley, MN 55422

Scarborough, Ontario

M1V 4Z9