Table of Contents | Breckwell SP 6000 specification

TABLE OF CONTENTS
INTRODUCTION	i
SAFETY PRECAUTIONS	ii
INSTALLATION	1
Specifications	1
Approved Installations	1
Preparation	1
Floor Protection	2
Venting	2
Combustion Air Supply	3
Electrical Installation	3
Special Mobile Home Requirements	4
Examples of Proper Installation	4
OPERATION	7
Proper Fuel	7
First Time Use Pre-Start Check	8
Lighting Directions	8
Control Panel	9
General Operation	9
Heat Level Light Indicators	12
Optional Thermostat	13
Control Panel Reset	14
SET THE CONTROL BOARD:	14
MAINTENANCE	15
Ash Disposal	15
Ash Removal	15
Vacuum Use	15
Cleaning	16
Recommended Maintenance Schedule	17
Removal and Replacement of Broken Door Glass	17
TROUBLESHOOTING GUIDE	18
Stove Shuts Off and the Second Light Flashes	18
Stove Shuts Off and the Third Light Flashes	19
Smoke Smell Coming Back Into The Home	20
Convection Blower Shuts Off and Comes Back On	20
Stove Will Not Feed Fuel, But Auger Light Does Come On	20
Dirty Burn	21
High Limit Switch Keeps Tripping	22
Digital Circuit Board Timing Rates	22
Stir Motor Timing Rates	22
REPLACEMENT PARTS	24

Image 2

Breckwell SP 6000 owner manual Table of Contents

Contents

Breckwell Hearth Products Table of Contents Introduction Safety Precautions Approved Installations InstallationSpecifications Preparation Equivalent Vent Length EVL Floor ProtectionVenting Electrical Installation Combustion Air Supply Horizontally Through Wall Examples of Proper InstallationSpecial Mobile Home Requirements Vertically With New Chimney System Vertically Into Existing Chimney System Installation Through Side of Masonry Chimney Vertically Into Existing Masonry Fireplace Shelled Corn OperationProper Fuel Wood Pellets First Time Use Pre-Start Check Lighting Directions Start-up Cycle Control PanelGeneral Operation Changing Heat Levels Blower Speeds Shut Down ProceduresDamper Control Restarting a warm stove Opening the Fuel Hopper Lid Heat Level Light Indicators Error Codes Thermostat Operation InstallationOptional Thermostat Control Panel Reset Ash Removal MaintenanceAsh Disposal Vacuum Use Blowers CleaningInterior Chambers Chimney & Vent Cleaning Recommended Maintenance ScheduleRemoval and Replacement of Broken Door Glass Troubleshooting Guide Stove Shuts Off and the Second Light Flashes Stove Shuts Off and the Third Light Flashes Stove Will Not Feed Fuel, But Auger Light Does Come On Smoke Smell Coming Back Into The HomeConvection Blower Shuts Off and Comes Back On Dirty Burn Stir Motor Timing Rates High Limit Switch Keeps TrippingDigital Circuit Board Timing Rates Electrical Diagram Tool Lifetime Limited Warranty