TROUBLESHOOTING
Although the manufacturer has attempted to ensure that your grill will operate properly and satisfactorily, some- times problems do arise. The following troubleshooting guide lists several possible problems and their probable cause and solution.
Problem | Cause | Solution |
Burner will not light. | Gas injector not inserted in venturi tube. | Realign/engage gas injector with the venturi tube. |
|
|
|
| Clogged gas injector. | Remove gas injector from gas control assembly |
|
| and clean. |
| Obstruction in gas line. | For propane models, ensure gas valve on cylin- |
|
| der is OFF. Remove flexible hose and blow out |
|
| any debris. |
| Spider webs in venturi tubes. | Clean venturi tubes. See Maintenance Section. |
| Misalignment of collector box and burner. | Position electrode properly. Clean collector box. |
|
|
|
| Out of gas. | Refill LP gas cylinder. If natural model, turn on |
|
| gas at source. |
| Dead battery. | Replace with AA Alkaline battery. |
Inadequate grill temperature. | Poor combustion. | Adjust air shutter. |
|
|
|
| Misalignment of venturi tube and gas injec- | Realign/engage gas injector with the venturi tube. |
| tor. |
|
| Inadequate gas pressure. | Contact gas supplier for assistance. |
| Incorrect orifice/valve setting. | Refer to gas conversion instructions in this |
|
| manual. |
Flames off the burner. | Cold grill. | Preheat grill at least 5 minutes on HI with the grill |
|
| lid open. |
| Misalignment of burner tube and gas injec- | Realign/engage gas injector with the burner tube. |
| tor. |
|
|
|
|
| Poor combustion. | Adjust air shutter. |
|
|
|
| Extreme wind. | Turn or shield grill. |
Yellow flames. | Air shutter improperly set. | Open air shutter. |
| Spider webs in venturi tubes. | Clean venturi tubes. See Maintenance Section. |
|
|
|
| Seasoning salts on burner. | Clean by washing burner with mild detergent. |
|
|
|
| Oil film on burner. | Allow burner to operate on HI for |
Low heat with knob in "High" posi- |
| Check for proper gas supply and pressure. |
tion. |
|
|
| ||
|
| |
|
|
|
|
| If using L.P. gas, check for empty tank. |
|
|
|
|
| Check for kinks in supply line. |
|
| If only one burner appears low, clean burner, |
|
| clearing ports of any obstructions. |
Infrared back burner won't light. |
| Check the burner inlet for obstructions. |
|
| Grill may be in a dusty area. Move to a less dusty |
|
| area if possible. |
Page 47 |
