TROUBLESHOOTING CHART:
See appropriate section in manual unless directed to Sears service center
PROBLEM | CAUSE | CORRECTION |
Mower blades will 1 Obstruction in clutch mechanism. 1 Remove obstruction. not rotate
|
|
| 2 | Worn/damaged |
| mower | drive | belt. | 2 | Replace | mower | drive | belt. |
| |||||||||||||||
|
|
| 3 | Frozen |
| idler | pulley. |
|
|
|
|
|
| 3 | Replace | idler | pulley. |
|
|
| |||||||||
|
|
| 4 | Frozen |
| blade | mandrel. |
|
|
|
| 4 | Contact |
| a Sears | or other |
|
| |||||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| qualified | service | center. |
|
| ||||||
Poor grass |
| 1 | Engine |
| speed | too | slow. |
|
|
| 1 | Place | throttle | control | in "FAST" | ||||||||||||||
discharge |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| position. |
|
|
|
|
|
|
|
| |||
|
|
| 2 | Travel | speed | too | fast. |
|
|
|
| 2 | Shift | to | slower | speed. |
|
|
| ||||||||||
|
|
| 3 | Wet | grass. |
|
|
|
|
|
|
|
|
|
| 3 | Allow | grass | to dry | before | mowing | ||||||||
|
|
| 4 | Mower |
| deck | not | level. |
|
|
|
| 4 | Level | mower |
| deck. |
|
|
|
| ||||||||
|
|
| 5 | Low/uneven |
| tire | air | pressure. |
| 5 | Check | tires | for proper | PSI. |
| ||||||||||||||
|
|
| 6 | Worn, | bent |
| or loose | blade. |
|
| 6 | Replace/sharpen | blade. | Tighten | |||||||||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| blade | bolt. |
|
|
|
|
|
|
| ||
|
|
| 7 | Buildup |
| of grass, | leaves | and |
| 7 | Clean |
| underside | of mower |
| ||||||||||||||
|
|
|
| trash | under |
| mower. |
|
|
|
|
|
| housing. |
|
|
|
|
|
|
|
| |||||||
|
|
| 8 | Mower |
| drive | belt worn. |
|
|
|
| 8 | Replace | mower | drive | belt. |
| ||||||||||||
|
|
| 9 | Blades |
| improperly |
| installed. |
|
| 9 | Reinstall | blades | sharp | edge | down | |||||||||||||
|
|
| 10 | Improper | blades | used. |
|
|
|
| 10 | Replace | with | blades listed | in | ||||||||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| this manual. |
|
|
|
|
|
|
| |||
|
|
| 11 | Clogged | mower | deck | vent | holes | 11 Clean around mandrels to |
| |||||||||||||||||||
|
|
|
| from | buildup | of grass, | leaves, | and |
| open | vent holes. |
|
|
|
|
| |||||||||||||
|
|
|
| trash | around | mandrels. |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| |||||||
Headlight(s) | not | 1 | Light | switch | is | "OFF". |
|
|
|
| 1 | Turn | light | switch | "ON". |
|
|
| |||||||||||
working |
|
| 2 | Bulb(s) |
| or | lamp(s) | burned | out. |
| 2 | Replace | bulb(s) | or | lamp(s). |
| |||||||||||||
(if so equipped) |
|
|
| ||||||||||||||||||||||||||
|
|
| 3 | Faulty | light | switch. |
|
|
|
|
|
| 3 | Check/replace | light | switch. |
| ||||||||||||
|
|
| 4 | Loose | or damaged |
| wiring. |
|
| 4 | Check | wiring |
| and connections. | |||||||||||||||
|
|
| 5 | Blown | fuse. |
|
|
|
|
|
|
|
|
| 5 | Replace | fuse. |
|
|
|
|
|
| ||||||
Battery | will | not | 1 | Bad | battery |
| cell(s). |
|
|
|
|
|
| 1 | Replace | battery. |
|
|
|
|
| ||||||||
charge |
|
| 2 | Poor | cable | connections. |
|
|
| 2 | Check/clean |
| all connections. |
| |||||||||||||||
|
|
|
|
|
|
|
| ||||||||||||||||||||||
|
|
| 3 | Faulty | regulator | (if so | equipped). | 3 | Replace | regulator. |
|
|
|
| |||||||||||||||
|
|
| 4 | Faulty | alternator. |
|
|
|
|
|
|
| 4 | Replace | alternator. |
|
|
|
| ||||||||||
Loss of | drive | 1 | Freewheel | control |
| in |
|
|
|
| 1 | Place | freewheel | control | in |
| |||||||||||||
|
|
|
| "DISENGAGED" |
| position. |
|
|
|
| "ENGAGED" |
| position. |
|
|
| |||||||||||||
|
|
| 2 | Debris | on steering | plate | (if |
|
| 2 | See | "CLEANING" |
| in the |
|
| |||||||||||||
|
|
|
| equipped). |
|
|
|
|
|
|
|
|
|
|
| maintenance |
| section. |
|
|
|
3Motion drive belt worn, damaged, 3 Replace motion drive belt. or broken.
4Air trapped in transmission during 4 Purge transmission. shipment or servicing.
5 Axle key missing. | 5 Install | axle key at rear wheel. See |
| "TO REMOVE WHEEL" in the | |
| Service | and Adjustments section. |
31