
| Symptom | Possible Cause | 
 | 
 | 
 | 
 | Possible Solution | 
 | 
 | ||
| Grinding, screeching, or rubbing noise | 1. Drum bearings lack sufficient grease. | 1. Grease the pillow bearings (Page 26). | ||||||||
| when sanding drums are powered up. | 2. Drum bearings are worn | and | need | 2. Replace the drum bearings. | 
 | |||||
| 
 | replacement. | 
 | 
 | 
 | 
 | 
 | 
 | 
 | 
 | |
| 
 | 
 | 
 | 
 | 
 | 
 | |||||
| Short  | 1. Pulleys not aligned correctly. | 
 | 
 | 1. Align pulleys (Page 31). | 
 | |||||
| 
 | 2. Improperly tensioned. | 
 | 
 | 
 | 2. Properly tension  | |||||
| 
 | 
 | 
 | 
 | 
 | 
 | 
 | 
 | |||
| Machine lacks power; drums stop turning | 1.  | 
 | 
 | 
 | 
 | 1. Tighten  | 
 | |||
| under load. | 2. Too much pressure on pressure roll- | 2. Reduce pressure roller pressure (Page | ||||||||
| 
 | ers. | 
 | 
 | 
 | 
 | 
 | 36). | 
 | 
 | 
 | 
| 
 | 
 | 
 | 
 | 
 | 
 | |||||
| Conveyor slips under load. | 1. Conveyor is too loose. | 
 | 
 | 
 | 1. Tension conveyor (Page 32). | |||||
| 
 | 2. Too much load. | 
 | 
 | 
 | 
 | 2. Decrease load. | 
 | 
 | ||
| 
 | 
 | 
 | 
 | |||||||
| Conveyor tracks to one side; conveyor | 1. Conveyor tracking is incorrect. | 
 | 1. Track the conveyor so it runs straight | |||||||
| hits the roller cover. | 
 | 
 | 
 | 
 | 
 | 
 | (Page 32). | 
 | 
 | 
 | 
| 
 | 
 | 
 | 
 | 
 | ||||||
| Workpiece pulls to one side during sand- | 1. One of the sanding drums is not paral- | 1. Adjust the | sanding drums | parallel to | ||||||
| ing operations. | lel with the table. | 
 | 
 | 
 | 
 | the table (Page 33). | 
 | 
 | ||
| 
 | 
 | 
 | ||||||||
| Excessive snipe. | 1. Too much pressure from all the pres- | 1. Reduce pressure roller pressure (Page | ||||||||
| 
 | sure rollers. | 
 | 
 | 
 | 
 | 
 | 36). | 
 | 
 | 
 | 
| 
 | 2. Too much pressure from the rear pres- | 2. Reduce rear pressure roller pressure | ||||||||
| 
 | sure rollers. | 
 | 
 | 
 | 
 | 
 | (Page 36). | 
 | 
 | 
 | 
| 
 | 3. Lack of outfeed support. | 
 | 
 | 
 | 3. Set up outfeed table or have someone | |||||
| 
 | 
 | 
 | 
 | 
 | 
 | 
 | catch the workpiece as it comes out. | |||
| 
 | 
 | 
 | 
 | 
 | 
 | |||||
| Workpiece kicks out of sander. | 1. Not enough pressure from the pressure | 1. Increase | pressure | roller | pressure | |||||
| 
 | rollers. | 
 | 
 | 
 | 
 | 
 | (Page 36). | 
 | 
 | 
 | 
| 
 | 
 | 
 | 
 | 
 | 
 | |||||
| Sandpaper tears off drums during opera- | 1. Nail/staple in workpiece. | 
 | 
 | 
 | 1. Sand only clean workpieces. | |||||
| tion. | 2. Sandpaper | not tightened | or | fastened | 2. Install the | sandpaper | correctly (Page | |||
| 
 | correctly. | 
 | 
 | 
 | 
 | 
 | 24). | 
 | 
 | 
 | 
| 
 | 3. Drums not | perpendicular | to | the | feed | 3. Adjust the drums perpendicular to the | ||||
| 
 | direction. | 
 | 
 | 
 | 
 | 
 | feed direction (Page 33). | 
 | ||
| 
 | 
 | 
 | 
 | 
 | 
 | 
 | 
 | |||
| Table elevation controls are stiff and hard | 1. Table lock is engaged. | 
 | 
 | 
 | 1. Disengage table lock. | 
 | 
 | |||
| to adjust. | 2. Table lift screws | are dirty or loaded | 2. Clean and | regrease | table | lift screws | ||||
| 
 | with sawdust. | 
 | 
 | 
 | 
 | (Page 27). | 
 | 
 | 
 | |
| 
 | 3. Chain idler | roller | sprocket | lock | nuts | 3. Adjust the lock nuts on the idler roller | ||||
| 
 | have been tightened against the roller. | sprocket so the roller can spin freely. | ||||||||
| 
 | 4. Elevation handle worm gear is dirty or | 4. Remove the worm gear box, clean it, | ||||||||
| 
 | loaded with sawdust. | 
 | 
 | 
 | and regrease it. | 
 | 
 | |||
| 
 | 
 | 
 | ||||||||
| Poor dust collection. | 1. The dust scoops are incorrectly posi- | 1. Experiment with the dust scoops moved | ||||||||
| 
 | tioned. | 
 | 
 | 
 | 
 | 
 | further in or out for better results. See | |||
| 
 | 
 | 
 | 
 | 
 | 
 | 
 | Page 37 for instructions on moving a | |||
| 
 | 
 | 
 | 
 | 
 | 
 | 
 | dust scoop. | 
 | 
 | |
| 
 | 2. Dust collection lines incorrectly | sized | 2. Use at least an 8" main line with two 6" | |||||||
| 
 | for this machine. | 
 | 
 | 
 | 
 | branch lines that each Y into 4" at the | ||||
| 
 | 
 | 
 | 
 | 
 | 
 | 
 | machine. | 
 | 
 | 
 | 
| 
 | 3. Dust collector underpowered or too far | 3. Upgrade your dust collector or decrease | ||||||||
| 
 | away from this machine. | 
 | 
 | 
 | the distance from the dust collector to | |||||
| 
 | 
 | 
 | 
 | 
 | 
 | 
 | the machine. | 
 | 
 | |
| 
 | 
 | 
 | 
 | 
 | 
 | 
 | 
 | 
 | 
 | 
 | 
| G0449/G0450 37" Drum Sander | 
