Models SL-550TV-IPI-E SL-750TV-IPI-E SL-950TV-IPI-E
What to do if you smell gas
Owner’s Manual
A. Congratulations
Homeowner Reference Information
Read this manual before installing or operating this appliance
Please retain this owner’s manual for future reference
Table of Contents
Safety Alert Key
Installer Guide
3 Maintenance and Service
14 Appliance Setup
15 Troubleshooting
A. Remove Glass Assembly B. Remove the Shipping Materials
C. Clean the Appliance D. Accessories
B. Limited Lifetime Warranty
Hearth & Home Technologies LIMITED WARRANTY
CONDITIONS, EXCLUSIONS & LIMITATION OF LIABILITY
B. Limited Lifetime Warranty continued
1 Listing and Code Approvals
A. Appliance Certification
B. Tempered Glass Specifications
C. BTU Specifications
D. High Altitude Installations
E. Non-Combustible Materials Specification
F. Combustible Materials Specification
G. Electrical Codes
A. Gas Fireplace Safety
2 Operating Instructions User Guide
B. Your Fireplace
F. Fixed Glass Assembly
G. Remote Controls, Wall Controls and Wall Switches
C. Fan Kit optional
E. Decorative Doors and Fronts
I. Lighting Instructions IPI
Final inspection by
FOR YOUR SAFETY READ BEFORE LIGHTING
1. Turn off all electric power to the appliance
K. Frequently Asked Questions
J. After Fireplace is Lit
ISSUE
SOLUTIONS
3 Maintenance and Service
A. Maintenance Tasks-Homeowner
Glass Cleaning
Remote Control
B. Maintenance Tasks-Qualified Service Technician
Gasket Seal and Glass Assembly Inspection
Venting
Logs
Either cobrahead or SIT
Figure 3.2 IPI Pilot Flame Patterns
Getting Started
A. Typical Appliance System
Installer Guide
FRAMING HEADED OFF IN CEILING JOISTS SECTION 8.B OPTIONAL WALL SWITCH
B. Design and Installation Considerations
C. Tools and Supplies Needed
D. Inspect Appliance and Components
E. Negative Pressure
5 Framing and Clearances
A. Selecting Appliance Location
F A
Model
B. Constructing the Appliance Chase
C. Clearances
MINIMUM FRAMING DIMENSIONS
D. Mantel and Wall Projections
Combustible Mantels
Note All measurements are in inches
Figure 5.4 Non-Combustible Zone
6 Termination Locations
A. Vent Termination Minimum Clearances
Fire Risk Maintain vent clearance to combustibles as specified
DO NOT pack air space with insulation or other materials
7 Vent Information and Diagrams
A. Vent Guidelines
B. Vent System Configuration
Vent this appliance directly outside
8 Vent Clearances and Framing
A. Pipe Clearances to Combustibles
B. Wall and Ceiling Penetration Framing
C. Vertical Penetration Framing
A. Installing Outside Air Kit Damper Assem- bly
9 Appliance Preparation
B. Gas and Electrical Connections
C. Securing and Leveling the Appliance
10 Installing Vent Pipe
A. Assembly of Vent Sections
D. Install Attic Insulation Shield
C. Securing Vent Sections
11 Gas Information
A. Fuel Conversion
B. Gas Pressure
C. Gas Connection
A. Wiring Requirements
C. Optional Accessories Requirements
D. Electrical Service and Repair
B. Intellifire Ignition System Wiring
BROWN
E. Junction Box Installation
F. Wall Switch Installation for Fan Optional
NOTICE DO NOT wire
110 VAC to wall switch
13 Finishing
A. Mantel and Wall Projections
Dimensions of Combustibles
Dimensions of Non-Combustibles
B. Facing Material
14 Appliance Setup
A. Remove Glass Assembly
C. Clean the Appliance
D. Accessories
E. Lava Rock, Mineral Wool/Ember Placement
Placing the Lava Rock
F. Install the Log Assembly
Log Set Assembly LOGS-550-E, 750-E, 950-E
Model SL-550TR-E, 750TR-E, 950TR-E SL-550TV-E, SL-750TV-E, SL-950TV-E
Log #3 Locate the pin hole on the underside of log #3. Mate the pin hole with the shoulder screw located on the burner top. Push the left end of log # 3 toward the back of the firebox until it touches the lava rock retainer
G. Fixed Glass Assembly
H. Install the Mesh
I. Install Trim and/or Surround
J. Install Hood
15 Troubleshooting
A. Intellifire Ignition System
Symptom
A. Incorrect wiring
Intellifire Ignition System - continued
Symptom
Verify all connections to wiring diagram in manual. Verify
With fixed glass assembly in place, verify that flame is en
A. Appliance Dimension Diagram
16 Reference Materials
Figure 16.1 Appliance Dimensions
GAS LINE ACCESS
Log Set Assembly
B. Service Parts
SL-550TV-IPI-E
Service Parts Diagram
Service Parts List
SL-550TV-IPI-E
at Depot
Stocked
Service Parts
SL-750TV-IPI-E
Log Set Assembly
Service Parts Diagram
Service Parts List
SL-750TV-IPI-E
at Depot
Stocked
SL-950TV-IPI-E
Log Set Assembly
Service Parts
Service Parts Diagram
SL-950TV-IPI-E
Stocked
Service Parts List
at Depot
IPI Valve Assembly
Service Parts
SL-550 / 750 / 950TV-IPI-E
Stocked
C. Contact Information
and maintenance
installation and operation
DO NOT DISCARD THIS MANUAL