What to do if you smell gas
Models SL-550TV-IPI-E SL-750TV-IPI-E SL-950TV-IPI-E
Owner’s Manual
Please retain this owner’s manual for future reference
A. Congratulations
Homeowner Reference Information
Read this manual before installing or operating this appliance
3 Maintenance and Service
Table of Contents
Safety Alert Key
Installer Guide
C. Clean the Appliance D. Accessories
14 Appliance Setup
15 Troubleshooting
A. Remove Glass Assembly B. Remove the Shipping Materials
Hearth & Home Technologies LIMITED WARRANTY
B. Limited Lifetime Warranty
CONDITIONS, EXCLUSIONS & LIMITATION OF LIABILITY
B. Limited Lifetime Warranty continued
C. BTU Specifications
1 Listing and Code Approvals
A. Appliance Certification
B. Tempered Glass Specifications
G. Electrical Codes
D. High Altitude Installations
E. Non-Combustible Materials Specification
F. Combustible Materials Specification
2 Operating Instructions User Guide
A. Gas Fireplace Safety
B. Your Fireplace
E. Decorative Doors and Fronts
F. Fixed Glass Assembly
G. Remote Controls, Wall Controls and Wall Switches
C. Fan Kit optional
1. Turn off all electric power to the appliance
I. Lighting Instructions IPI
Final inspection by
FOR YOUR SAFETY READ BEFORE LIGHTING
SOLUTIONS
K. Frequently Asked Questions
J. After Fireplace is Lit
ISSUE
Remote Control
3 Maintenance and Service
A. Maintenance Tasks-Homeowner
Glass Cleaning
Logs
B. Maintenance Tasks-Qualified Service Technician
Gasket Seal and Glass Assembly Inspection
Venting
Figure 3.2 IPI Pilot Flame Patterns
Either cobrahead or SIT
FRAMING HEADED OFF IN CEILING JOISTS SECTION 8.B OPTIONAL WALL SWITCH
Getting Started
A. Typical Appliance System
Installer Guide
C. Tools and Supplies Needed
B. Design and Installation Considerations
D. Inspect Appliance and Components
E. Negative Pressure
Model
5 Framing and Clearances
A. Selecting Appliance Location
F A
C. Clearances
B. Constructing the Appliance Chase
MINIMUM FRAMING DIMENSIONS
Figure 5.4 Non-Combustible Zone
D. Mantel and Wall Projections
Combustible Mantels
Note All measurements are in inches
DO NOT pack air space with insulation or other materials
6 Termination Locations
A. Vent Termination Minimum Clearances
Fire Risk Maintain vent clearance to combustibles as specified
Vent this appliance directly outside
7 Vent Information and Diagrams
A. Vent Guidelines
B. Vent System Configuration
C. Vertical Penetration Framing
8 Vent Clearances and Framing
A. Pipe Clearances to Combustibles
B. Wall and Ceiling Penetration Framing
C. Securing and Leveling the Appliance
A. Installing Outside Air Kit Damper Assem- bly
9 Appliance Preparation
B. Gas and Electrical Connections
C. Securing Vent Sections
10 Installing Vent Pipe
A. Assembly of Vent Sections
D. Install Attic Insulation Shield
C. Gas Connection
11 Gas Information
A. Fuel Conversion
B. Gas Pressure
B. Intellifire Ignition System Wiring
A. Wiring Requirements
C. Optional Accessories Requirements
D. Electrical Service and Repair
BROWN
110 VAC to wall switch
E. Junction Box Installation
F. Wall Switch Installation for Fan Optional
NOTICE DO NOT wire
Dimensions of Non-Combustibles
13 Finishing
A. Mantel and Wall Projections
Dimensions of Combustibles
B. Facing Material
D. Accessories
14 Appliance Setup
A. Remove Glass Assembly
C. Clean the Appliance
Placing the Lava Rock
E. Lava Rock, Mineral Wool/Ember Placement
Log Set Assembly LOGS-550-E, 750-E, 950-E
F. Install the Log Assembly
Model SL-550TR-E, 750TR-E, 950TR-E SL-550TV-E, SL-750TV-E, SL-950TV-E
Log #3 Locate the pin hole on the underside of log #3. Mate the pin hole with the shoulder screw located on the burner top. Push the left end of log # 3 toward the back of the firebox until it touches the lava rock retainer
J. Install Hood
G. Fixed Glass Assembly
H. Install the Mesh
I. Install Trim and/or Surround
A. Incorrect wiring
15 Troubleshooting
A. Intellifire Ignition System
Symptom
With fixed glass assembly in place, verify that flame is en
Intellifire Ignition System - continued
Symptom
Verify all connections to wiring diagram in manual. Verify
GAS LINE ACCESS
A. Appliance Dimension Diagram
16 Reference Materials
Figure 16.1 Appliance Dimensions
Service Parts Diagram
Log Set Assembly
B. Service Parts
SL-550TV-IPI-E
Stocked
Service Parts List
SL-550TV-IPI-E
at Depot
Service Parts Diagram
Service Parts
SL-750TV-IPI-E
Log Set Assembly
Stocked
Service Parts List
SL-750TV-IPI-E
at Depot
Service Parts Diagram
SL-950TV-IPI-E
Log Set Assembly
Service Parts
at Depot
SL-950TV-IPI-E
Stocked
Service Parts List
Stocked
IPI Valve Assembly
Service Parts
SL-550 / 750 / 950TV-IPI-E
DO NOT DISCARD THIS MANUAL
C. Contact Information
and maintenance
installation and operation