IBM T60P Symptom-to-FRU index , 50

Symptom or error FRU or action, in sequence

0190

Critical low-battery error

1. Charge the battery pack.

2. Battery pack.

0191

System Security—Invalid Remote Change

requested.

1. Run BIOS Setup Utility, and then save

current setting by pressing F10.

2. System board.

0192

System Security— Embedded Security

hardware tamper detected.

System board.

0199

System Security— Security password retry

count exceeded.

1. Run BIOS Setup Utility, and then save

the current setting by pressing F10.

2. System board.

01C8

Two or more modem devices are found.

Remove all but one of them. Press <Esc> to

continue.

1. Remove either a Mini-PCI Card or a

modem daughter card. Otherwise, press

Esc to ignore the warning message.

2. System board.

01C9

More than one Ethernet devices are found.

Remove one of them. Press <Esc> to

continue.

1. Remove the Ethernet device that you

installed; or press Esc to ignore the

warning message.

2. System board.

01CA

More than one Wireless LAN devices are

found. Remove one of them.

1. Remove the wireless LAN device that

you installed.

2. System board.

0200

Hard disk error—The hard disk is not

working.

1. Reseat the hard disk drive.

2. Load Setup Defaults in BIOS Setup

Utility.

3. Hard disk drive.

4. System board.

021x

Keyboard error.

Run interactive tests of the keyboard and

the auxiliary input device.

0220

Monitor type error—Monitor type does not

match the one specified in CMOS.

Load Setup Defaults in BIOS Setup Utility.

0230

Shadow RAM error—Shadow RAM fails at

offset nnnn.

System board.

0231

System RAM error—System RAM fails at

offset nnnn.

1. DIMM.

2. System board.

0232

Extended RAM error— Extended RAM fails

at offset nnnn.

1. DIMM.

2. System board.

0250

System battery error—System battery is

dead.

1. Charge the backup battery for more

than 8 hours by connecting the ac

adapter.

2. Replace the backup battery and run BIOS

Setup Utility to reset the time and date.

0251

System CMOS checksum bad— Default

configuration used.

1. Charge the backup battery for more

than 8 hours by connecting the ac

adapter.

2. Replace the backup battery and run BIOS

Setup Utility to reset the time and date.

Symptom-to-FRU index

50 MT 1951, 1952, 1953, 1954, 1955, 1956, 2007, 2008, 2009, 2613, 2623, and 2637

Contents

Main ThinkP ad T60 and T60p (1 4. 1-in ch and 15.0-inch) Hardware Maintenance Manual Page Page Page Contents About this manual . . . . . . . . . .1 Introduction . . . . . . . . . . . . .3 Copyright Lenovo 2006, 2008 General descriptions . . . . . . . . .23 ThinkPad T60 and T60p (14.1-inch and 15.0-inch) . . . . . . . . . . . . .37 iv About this manual Copyright Lenovo 2006, 2008 2 Introduction Important service information Copyright Lenovo 2006, 2008 Strategy for replacing FRUs Strategy for replacing a hard disk drive 4 Important notice for replacing a system board How to use error messages Strategy for replacing FRUs for CTO, CMV, and GA V Product definition FRU identification for CTO, CMV, and GA V products Introduction 5 Using PEW Using eSupport Using the HMM Important information about replacing RoHS compliant FRUs Current or original part Replacement FRU Current or original part Important service information Diskette compatibility matrix Introduction 7 drive Diskette capacity Diskette compatibility matrix Safety notices: multilingual translations 8 Safety notices Safety notice 2 Introduction 9 Safety notice 3 10 Safety notice 4 Introduction Safety notice 5 Safety notices 12 Safety notice 6 Introduction 13 Safety notice 7 Safety notices 14 Safety notice 8 Introduction 15 Safety information 16 Observe the following rules when working on electrical equipment. General safety Electrical safety Introduction 17 Safety inspection guide 18 Safety information Handling devices that are sensitive to electrostatic discharge Introduction 19 Grounding requirements Laser compliance statement 20 CAUTION: Laser compliance statement Introduction 21 22 General descriptions Copyright Lenovo 2006, 2008 Read this first Before you go to the checkout guide, be sure to read this section. What to do first Read this first 24 Related service information General descriptions 25 Service Web site Restoring the factory contents by using Product Recovery discs Passwords 26 Related service information General descriptions 27 How to remove the power-on password How to remove the hard-disk password Power management 28 Screen blank mode Standby mode Related service information Hibernation mode Related service information 30 Checkout guide General descriptions 31 Testing the computer Creating the PC-Doctor diagnostics diskette Wireless LAN Checkout guide 32 The options on the test menu are as follows: General descriptions 33 Detecting system information with PC-Doctor PC-Doctor can detect the following system information: Hardware Info Utility 34 Power system checkout Checking the ac adapter Checkout guide 1 2 Checking operational charging Checking the battery pack 6(-) 5 4 1(+)2(+)3 7(-) Black (-) Checking the backup battery 36 Wire Voltage (V dc) Red +2.5 to +3.2 Black Ground Checkout guide ThinkPad T60 and T60p (14.1-inch and 15.0-inch) Copyright Lenovo 2006, 2008 Product overview 38 (continued) Processor v Intel Specifications ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 39 40 Status indicators The system status indicators show the status of the computer, as follows: ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 41 1 2 3 4 5 6 7 8 9 10 8910 Product overview 42 Indicator Meaning 9 AC power Green: The computer is connected to the ac power supply. 10 Standby status ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 43 FRU tests The following table shows the test for each FRU. 44 (continued) Product overview ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 45 Fn key combinations 46 (continued) Product overview ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 47 48 Symptom-to-FRU index ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 49 System board. Numeric error codes 0175 Bad CRC1, stop POST taskThe EEPROM checksum is not correct. Symptom-to-FRU index 50 Page Symptom-to-FRU index 52 Error messages ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 53 Device Error. 1. The device you want to boot from. Beep symptoms One beep and a blank, unreadable, or flashing LCD. 54 System board (security chip) Five short beeps and a blank screen. System board No-beep symptoms LCD-related symptoms ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 55 XGA, WXGA 5 6 6 WXGA+, SXGA+, WSXGA+ 5 8 10 UXGA, WUXGA, QXGA 5 13 13 Intermittent problems 56 Undetermined problems Symptom-to-FRU index FRU replacement notices ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 57 (Cross-section) Screw notices 90degrees more Restoring the serial number of the system unit 58 Retaining the UUID Reading or writing the ECA information FRU replacement notices ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 59 Removing and replacing a FRU 60 Removing and replacing a FRU FRU compatibility matrix (continued) Removing and replacing a FRU 62 1010 Battery pack ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 63 1 2 1020 Ultrabay Slim device Removing and replacing a FRU 64 For access, remove this FRU: ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 65 (continued) 1 Hard disk drive screw, nylon-coated (1) Black 0.167 Nm When installing: Make sure that the hard disk drive connector is attached firmly. Removing and replacing a FRU 66 1040 Palm rest or palm rest with fingerprint reader For access, remove this FRU in order: ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 67 (continued) (4) Removing and replacing a FRU 68 ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 69 Note: Make sure that the frame and the front side of the palm rest are attached firmly. (continued) Removing and replacing a FRU 70 ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 71 (continued) Removing and replacing a FRU 72 ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 73 1050 DIMM For access, remove these FRUs in order: v 1010 Battery pack on page 63 74 Removing and replacing a FRU 1060 Keyboard For access, remove these FRUs in order: v 1010 Battery pack on page 63 ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 75 (1) 1 Removing and replacing a FRU 76 1070 Modem daughter card (MDC-1.5) ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 77 1 M2 3 mm, small-head, nylon-coated (2) Silver 0.167 Nm Turn the card over 3 , and detach the modem connector 4 . Removing and replacing a FRU 78 1080 PCI Express Mini Card for 802.11 a/b/g wireless LAN ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 79 2 M2 9.5 mm, flat-head, nylon-coated (2) Black 0.167 Nm For 15.0-in. LCD models: Removing and replacing a FRU 80 1090 PCI Express Mini Card for 802.11 a/b/g/n wireless LAN ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 81 2 M2 9.5 mm, flat-head, nylon-coated (2) Black 0.167 Nm For 15.0-in. LCD models: Removing and replacing a FRU 82 1100 PCI Express Mini Card for wireless WAN ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 83 2 M2 3 mm, small-head, nylon-coated (2) Silver 0.167 Nm Removing and replacing a FRU 84 1110 Backup battery ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 85 When installing: Make sure that the battery connector is attached firmly. 1120 Keyboard bezel and wireless WAN antenna cable (AUX) 86 (continued) Note: removing it, remove the keyboard bezel first. Removing and replacing a FRU ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 87 Note: Steps 8 and 9 are for the wireless WAN antenna cable (AUX). When installing: Make sure that the antenna cable is routed along the cable guides. 88 1130 Fan assembly ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 89 (continued) Removing and replacing a FRU 90 ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 91 (continued) Removing and replacing a FRU 92 1140 CPU ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 93 1150 LCD assembly 94 (continued) 1 M2 9.5 mm, flat-head, nylon-coated (2) Black 0.167 Nm Removing and replacing a FRU For models with 14.1-in. LCD: 3 M2 5 mm, flat-head, nylon-coated (2) Black 0.167 Nm ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 95 For models with 15.0-in. LCD: 3 M2 5 mm, flat-head, nylon-coated (3) Black 0.167 Nm 96 ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 97 1160 Base cover 98 (continued) 1 M2 5 mm, flat-head, nylon-coated (6) Black 0.167 Nm Removing and replacing a FRU (continued) 1a 1 , 1a M2 5 mm, flat-head, nylon-coated (8) Black 0.167 Nm 100 Note: Screw 6 is only for the 14.1-in. LCD models. ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 101 Note: Steps later 7 are common for the 14.1-in. LCD models and 15.0-in. LCD models. not popped out. It must be housed in its position as shown in the figure a. a Removing and replacing a FRU 102 1170 Speaker assembly ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 103 When installing: Make sure that the speaker connector is attached firmly. 1180 USB sub card with cable 104 When installing: Make sure that the connector 1 is attached firmly. (continued) Removing and replacing a FRU Turn over the structure frame and proceed to step 2 . ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 105 1190 SIM card slot 106 1 M2 3.5 mm, flat-head, nylon-coated (1) Black 0.167 Nm When installing: Make sure the connector 2 is attached firmly. Removing and replacing a FRU 1200 Structure frame ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 107 (continued) 1 M2 3 mm, flat-head, nylon-coated (1) Silver 0.167 Nm Remove the ac power jack cable a and the modem cable b . Removing and replacing a FRU 108 Remove the CPU support plate. 7 M2 5 mm, flat-head, nylon-coated (1) Black 0.167 Nm ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 109 (continued) 99 Removing and replacing a FRU 110 ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 2. Secure the screws in order as shown in this figure. (continued) 14.1-in. LCD models: Removing and replacing a FRU 112 15.0-in. LCD models: 1210 System board, PC Card/ExpressCard slots assembly and interposer card 114 running. Removing and replacing a FRU Page 116 2010 LCD front bezel For 15.0-in. LCD models: 1 nylon-coated (3) Removing and replacing a FRU 118 2020 Inverter card For access, remove these FRUs in order: v 1010 Battery pack on page 63 ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 1 M2 4 mm, flat-head, nylon-coated (1) Black 0.167 Nm 2030 Bluetooth daughter card (BDC-2) For access, remove these FRUs in order: v 1010 Battery pack on page 63 120 For 14.1-in. LCD models: 1 M2 4 mm, flat-head, nylon-coated (1) Black 0.167 Nm 2040 Wireless WAN antenna cable (MAIN) or wireless WAN blank cover ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 121 2 M2 2.8 mm, flat-head, nylon-coated (2) Silver 0.118 Nm (1.2 kgfcm) Removing and replacing a FRU 122 ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 123 2050 LCD panel, LCD cable, and hinges 124 (continued) Removing and replacing a FRU Remove the hinges ( a ) from the LCD panel. 4 M2 2.8 mm, flat-head, nylon-coated (4) Silver 0.167 Nm ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 125 Remove the LCD cable assembly ( b ) from the LCD panel. For 15.0-in. LCD models: 126 2060 LCD rear cover and wireless LAN antenna cables ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 127 1 M2 2.8 mm, flat-head, nylon-coated (4) Silver 0.118 Nm (1.2 kgfcm) Locations Front view 128 16 15 17 Rear view ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 129 Bottom view Locations Parts list Overall b 130 c a d (continued) 42W2670 R N 132 No. FRU FRU no. RoHS ID ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 133 42W2225 R N No. FRU FRU no. RoHS ID 42W2226 R N Parts list 134 No. FRU FRU no. RoHS ID ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 135 42W3009 R ** No. FRU FRU no. RoHS ID 41V9907 R ** Parts list 136 No. FRU FRU no. RoHS ID ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 137 No. FRU FRU no. RoHS ID Parts list 138 No. FRU FRU no. RoHS ID ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 139 41V9987 R N No. FRU FRU no. RoHS ID 42R9911 R N Parts list 140 No. FRU FRU no. RoHS ID ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 141 42R9912 R N No. FRU FRU no. RoHS ID Parts list 142 No. FRU FRU no. RoHS ID ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 143 39T2759 R * No. FRU FRU no. RoHS ID Parts list 144 No. FRU FRU no. RoHS ID ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 145 41W1130 N 13 Backup battery 02K6572 R ** No. FRU FRU no. RoHS ID Parts list 146 No. FRU FRU no. RoHS ID ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 147 No. FRU FRU no. RoHS ID Parts list 148 No. FRU FRU no. RoHS ID ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 149 13N5108 R * No. FRU FRU no. RoHS ID 41V9985 R * Parts list 150 No. FRU FRU no. RoHS ID ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 151 41V9986 R * No. FRU FRU no. RoHS ID 41V9937 R N Taiwan v 1951-xxV Parts list 152 Page No. FRU FRU no. RoHS ID 41V9943 R N Taiwan v 2007-CTO, xxV 41V9967 R N Taiwan v 2007-CTO, xxV 41V9944 R N Taiwan v 2008-CTO, xxV Parts list 154 Page No. FRU FRU no. RoHS ID 40Y8401 R ** 40Y8402 R ** Parts list 156 No. FRU FRU no. RoHS ID ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 157 40Y8403 R ** 40Y8404 R ** No. FRU FRU no. RoHS ID Parts list 158 No. FRU FRU no. RoHS ID ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 159 41W1364 R N 41W1454 R N 41W1368 R N Parts list 160 Page No. FRU FRU no. RoHS ID 41W1134 R N 41W1136 R N Parts list 162 No. FRU FRU no. RoHS ID ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 163 41W1138 R N 41W1327 R N 41W1409 R N Parts list 164 Page No. FRU FRU no. RoHS ID 41V9769 R N Parts list 166 No. FRU FRU no. RoHS ID ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 167 41V9770 R N 41V9931 R N No. FRU FRU no. RoHS ID Parts list 168 No. FRU FRU no. RoHS ID ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 169 41W6407 R N 41W1177 R ** No. FRU FRU no. RoHS ID Parts list 170 LCD FRUs 14.1-in. XGA TFT ID 172 13N7135 R N 91P6988 R N No. FRU FRU no. RoHS ID ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 173 42W2671 R N 41V9909 R * 42R9909 R N 174 No. FRU FRU no. RoHS ID ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 175 No. FRU FRU no. RoHS ID Parts list 176 No. FRU FRU no. RoHS ID ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 177 41W1010 R N No. FRU FRU no. RoHS ID Parts list 178 No. FRU FRU no. RoHS ID ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 179 14.1-in. SXGA+ TFT ID 180 13N7135 R N 91P6988 R N No. FRU FRU no. RoHS ID ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 181 91P7028 R N 41V9909 R * 42R9909 R N 182 No. FRU FRU no. RoHS ID ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 183 No. FRU FRU no. RoHS ID Parts list 184 No. FRU FRU no. RoHS ID ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 185 41W1010 R N No. FRU FRU no. RoHS ID Parts list 186 No. FRU FRU no. RoHS ID ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 187 15.0-in. XGA TFT ID 188 13N7136 R N 91P6989 R N No. FRU FRU no. RoHS ID ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 189 41V9910 R * 42R9910 R N 91P6983 R N 190 No. FRU FRU no. RoHS ID ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 191 42T0077 R N No. FRU FRU no. RoHS ID 39T0497 R N Parts list 192 15.0-in. SXGA+ IPS TFT ID ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 193 13N7136 R N 91P6989 R N Parts list 194 No. FRU FRU no. RoHS ID ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 195 91P6985 R N No. FRU FRU no. RoHS ID 42R9908 R N Parts list 196 No. FRU FRU no. RoHS ID ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 197 42T0079 R N No. FRU FRU no. RoHS ID 39T0497 R N Parts list 198 15.0-in. UXGA IPS TFT Parts list 200 Page No. FRU FRU no. RoHS ID 91P6987 R N 42T0079 R N Parts list 202 Page Keyboard Parts list 204 Recovery discs Windows XP Professional CDs ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 205 Parts list 206 ID ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 207 Windows XP Home Edition CDs 208 ID Parts list ID ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 209 Windows Vista Home Premium (32 bit) DVDs 210 ID Parts list Windows Vista Business (32 bit) DVDs ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 211 ID Windows Vista Ultimate (32 bit) DVDs 212 ID Parts list Miscellaneous parts ID ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 213 41W4504 R N 41V9926 R N Parts list 214 AC adapters ID ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 215 Common parts list Tools Power cords 216 (Longwell) P/N (Volex) RoHS ID For 3-pin power cords: Notices ThinkPad T60 and T60p (14.1-inch and 15.0-inch) 217 Notices Trademarks Notices 218