ThinkPad Computer Hardware Maintenance Manual
September This manual supports ThinkPad X40 Series
MT 2369, 2370, 2371
All rights reserved
First Edition September Copyright Lenovo
Portions Copyright International Business Machines Corporation
Introduction
Contents
About this manual
General descriptions
Undetermined problems
About this manual
2 MT 2369/2370/2371/2372/2382/2386
Strategy for replacing FRUs
Important service information
Introduction
Strategy for replacing FRUs for CTO, CMV, and GAV Product definition
How to use error messages
Strategy for replacing a hard disk drive
Dynamic Configure To Order CTO
FRU identification for CTO, CMV, and GAV products
Using PEW
Using eSupport
Using the HMM
Important information about replacing RoHS compliant FRUs
Safety notices multilingual translations
Diskette compatibility matrix
Safety notice
Safety notices
Safety notice DANGER
Algunas baterías de reserva contienen una pequeña cantidad de níquel y cadmio. No las desmonte, ni recargue, ni las eche al fuego o al agua ni las cortocircuite. Deséchelas tal como dispone la normativa local. Utilice sólo baterías que se encuentren en la lista de piezas. La utilización de una batería no apropiada puede provocar la ignición o explosión de la misma
La batterie contient du nickel. Ne la démontez pas, ne l’exposez ni au feu ni à l’eau. Ne la mettez pas en court-circuit. Pour la mettre au rebut, conformez-vous à la réglementation en vigueur. Lorsque vous remplacez la batterie, veillez à n’utiliser que les modèles cités dans la liste de pièces détachées adéquate. En effet, une batterie inappropriée risque de prendre feu ou d’exploser
La batteria contiene piccole quantità di nichel. Non smontarla, gettarla nel fuoco o nell’acqua né cortocircuitarla. Smaltirla secondo la normativa in vigore DPR 915/82, successive disposizioni e disposizioni locali. Quando si sostituisce la batteria, utilizzare soltanto i tipi inseriti nell’appropriato Catalogo parti. L’impiego di una batteria non adatta potrebbe determinare l’incendio o l’esplosione della batteria stessa
The lithium battery can cause a fire, an explosion, or a severe burn. Do not recharge it, remove its polarized connector, disassemble it, heat it above 100C 212F, incinerate it, or expose its cell contents to water. Dispose of the battery as required by local ordinances or regulations. Use only the battery in the appropriate parts listing. Use of an incorrect battery can result in ignition or explosion of the battery
La batería de repuesto es una batería de litio y puede provocar incendios, explosiones o quemaduras graves. No la recargue, ni quite el conector polarizado, ni la desmonte, ni caliente por encima de los 100C 212F, ni la incinere ni exponga el contenido de sus celdas al agua. Deséchela tal como dispone la normativa local
16 MT 2369/2370/2371/2372/2382/2386
To avoid shock, do not remove the plastic cover that protects the lower part of the inverter card
18 MT 2369/2370/2371/2372/2382/2386
Avant de retirer une unité remplaçable en clientèle, mettez le système hors tension, débranchez tous les cordons d’alimentation des socles de prise de courant, retirez la batterie et déconnectez tous les cordons d’interface
Safety information
General safety
Electrical safety
handling
v Do not use worn or broken tools and testers
Safety inspection guide
Handling devices that are sensitive to electrostatic discharge
Introduction
Grounding requirements
Use the round ground prong of the ac plug on ac-operated computers
Laser compliance statement
Use of controls or adjustments or performance of procedures other than those specified herein might result in hazardous radiation exposure
DANGER
What to do first
General descriptions
Read this first
Note for warranty
The following are not covered under warranty
Creating a Recovery Repair diskette
Related service information
Service Web site
Restoring the preloaded system
Product Recovery program
4. Select Create a Recovery Repair diskette. Press Enter
Reinstall the Product Recovery program? Y/N ”
Using the recovery CD
To create the service partition
Install preloaded system from CD
Recovering the hard disk using Access IBM Predesktop Area
Recovering the hard disk to original contents
To use the Recovery Repair diskette
Recovering the hard disk using the recovery CD
Reinstall the Product Recovery program? Y/N ”
Install preloaded system from CD
Hard disk password
Passwords
Power-on password
Supervisor password
B If an SVP has been set and is known by the servicer
How to remove the power-on password
How to remove the hard disk password
A If no SVP has been set
Power management
Screen blank mode
Standby mode
Note for the APM operating system
Note for OS/2
Hibernation mode
Note for Windows NT
Testing the computer
Checkout guide
Checkout guide
Creating the PC-Doctor diagnostics diskette
Diagnostics
Interactive Tests
Hardware Info
Power system checkout
Detecting system information with PC-Doctor
Utility
Pin Voltage V dc
Checking the ac adapter
Checking operational charging
Checking the battery pack
Checking the backup battery
Voltage V dc
Red + Black
Wire
50 MT 2369/2370/2371/2372/2382/2386
Checkout guide
ThinkPad X40 series
Power cords system
Recovery CDs
Common parts list
For Windows XP Professional
Feature
Specifications
Product overview
Description
Description
Feature
54 MT 2369/2370/2371/2372/2382/2386
ThinkPad X40 series
Status indicators for
continued
56 MT 2369/2370/2371/2372/2382/2386
continued
FRU tests
The following table shows the test for each FRU
ThinkPad X40 series
58 MT 2369/2370/2371/2372/2382/2386
Fn key combinations
of keys are pressed, a list of wireless features is
60 MT 2369/2370/2371/2372/2382/2386
Symptom-to-FRU index
Numeric error codes
continued
62 MT 2369/2370/2371/2372/2382/2386
Symptom or error
continued
64 MT 2369/2370/2371/2372/2382/2386
continued
ThinkPad X40 series
continued
66 MT 2369/2370/2371/2372/2382/2386
ThinkPad X40 series
68 MT 2369/2370/2371/2372/2382/2386
Error messages
continued
ThinkPad X40 series
70 MT 2369/2370/2371/2372/2382/2386
Beep symptoms
No-beep symptoms
LCD-related symptoms
Intermittent problems
Undetermined problems
90 degrees more Cross-section
FRU replacement notices
Screw notices
180 degrees more Cross-section
Retaining serial numbers
Restoring the serial number of the system unit
Retaining the UUID
Reading or writing the ECA information
76 MT 2369/2370/2371/2372/2382/2386
Removing and replacing a FRU
Removing and replacing a FRU
Before processing, seperate main unit from docking first
1010 Battery pack
to remove the battery pack
Release the lock knob, shown as
Screw quantity
1020 Hard disk drive
Step
Torque
Note Loosen the screws
1030 DIMM cover
For access, remove following FRU v “1010 Battery pack” on page
but do not remove them
1040 Mini PCI adapter, DIMM, MDC-2, and BMDC-2
AUX MAIN
continued
Or remove BMDC-2 ThinkPad Integrated Bluetooth III with 56K Modem
Remove MDC-2 ThinkPad Integrated 56K Modem
82 MT 2369/2370/2371/2372/2382/2386
ThinkPad X40 series
When installing, route the modem cable as shown below
Note The bluetooth cable should be routine between planar and BMDC
Removing and replacing a FRU
0.196 Nm
1050 Keyboard
M2 × 6 mm, nylon-coated
2 kgfcm
ThinkPad X40 series
Detach the keyboard connector to remove the keyboard
Then lift up the keyboard slightly, as shown in step
Gently push the keyboard forward, as shown in step
When installing Follow the steps below 1. Attach the connector
1060 Upper case
Gently push the upper case backward, as shown in step
Detach cover switch cablesuspend cable, shown as
and microphone cable, shown as
And lift it up slightly, as shown in step
ThinkPad X40 series
Note After installing upper case, arrange antenna as
If BMDC II is used, arrange antenna as
1070 Backup battery
DANGER
1080 LCD module
92 MT 2369/2370/2371/2372/2382/2386
Then remove the four screws as shown
continued
Removing and replacing a FRU
Remove LCD module
ThinkPad X40 series
1090 Hard disk housing assembly
1a 1a 1b 1b
1100 Top shielding
1b 1a 1a 1b
1110 Lower case
ThinkPad X40 series
Remove the two screws at the bottom
continued
Step
98 MT 2369/2370/2371/2372/2382/2386
Remove lower case
continued
Step
Removing and replacing a FRU
When installing Becareful to align with the 2 location notches
ThinkPad X40 series
1120 Fansink
2010 LCD bezel
102 MT 2369/2370/2371/2372/2382/2386
Remove LCD bezel
continued
1a 1b
ThinkPad X40 series
Removing and replacing a FRU
2020 LCD
2030 Inverter card
cable, as shown in step
When installing Attach the inverter back to its original
position, as shown in step
Then
2040 Antenna L and antenna R
1a 1b
108 MT 2369/2370/2371/2372/2382/2386
shown as and , before securing it with the two screws
continued
2b 2a
ThinkPad X40 series
Remove the antenna R Note For FRU LCD 92P6687 ID Tech, remove the
continued
5a 5b
4b 4a
2050 Hinge L and hinge R
Step
Remove hinge R
112 MT 2369/2370/2371/2372/2382/2386
Screw quantity
2060 Bluetooth antenna cable
Security keyhole Modem connector Ethernet connector USB connector
Locations Front view for X40 series
Computer display System status indicators Power switch
PC card slot TrackPoint button TrackPointing stick Access IBM button
Bluetooth status indicators AC Power connector
Rear view for X40 series
LCD latch Standby status indicators Battery status indicators
External monitor connector Powered USB 2.0 connector
Battery pack latches Battery pack
Bottom view for X40 series
Hard disk drive Mini-PCI and memory door Docking connector
116 MT 2369/2370/2371/2372/2382/2386
ThinkPad X40 series
Front View for X4 UltraBase Dock
Foot
RJ11 modem connector USB connectors PS/2 keyboard or mouse connector
Rear View for X4 UltraBase Dock
AC-in port CRT port Serial port Parallel port RJ45 ethernet connector
Security keyhole System eject button System eject lever
Parts list Overall
Parts list
Page
Parts list
continued
122 MT 2369/2370/2371/2372/2382/2386
continued
ThinkPad X40 series
continued
124 MT 2369/2370/2371/2372/2382/2386
ThinkPad X40 series
Parts list
continued
continued
126 MT 2369/2370/2371/2372/2382/2386
Page
continued
128 MT 2369/2370/2371/2372/2382/2386
continued
ThinkPad X40 series
continued
130 MT 2369/2370/2371/2372/2382/2386
continued
ThinkPad X40 series
continued 132 MT 2369/2370/2371/2372/2382/2386
ThinkPad X40 series
LCD FRUs
12.1-in. XGA TFT
ThinkPad X40 series
Keyboard
136 MT 2369/2370/2371/2372/2382/2386
P/N NMB
ThinkPad X40 series
Language
Chicony
Recovery CDs
For Windows XP Professional
ThinkPad X40 series
Language
For Windows XP Home Edition
Miscellaneous parts
ThinkPad X40 series
For 2-pin power cords
Common parts list
Power cords system
Tools
For 3-pin power cords
For Models-xxC, xxM, xxA, xxG, xxH, xxK
Telephone cable
144 MT 2369/2370/2371/2372/2382/2386
Research Triangle Park, NC U.S.A
Notices
Lenovo United States, Inc 500 Park Offices Drive, Hwy
Attention Lenovo Director of Licensing
146 MT 2369/2370/2371/2372/2382/2386
Trademarks
Trademarks
Part Number 39T5972
1P P/N 39T5972