![](/images/new-backgrounds/1301931/30193169x1.webp)
TROUbLESHOOTING | ||
|
|
|
| Observe all Safety Guidelines detailed throughout this manual |
|
PRObLEMS
(SYMPTOMS)
POSSIbLE
CAUSE
RECOMMENDED
COURSE OF ACTION
Major Physical or Electrical Damage 1. Contact your local | Lincoln |
| ||||
is Evident. |
| Authorized Field | Service |
| ||
|
| Facility. |
|
|
|
|
Engine will not "crank". | 1. Battery is low, Charge Battery. |
| ||||
| 2. | Loose battery cable connections. |
| |||
|
| Inspect, clean and tighten terminals. |
| |||
| 3. | Faulty engine starter motor. |
| |||
|
| Contact authorized local Engine |
| |||
|
| Service Shop. |
|
|
|
|
|
|
|
| |||
Engine will "crank" but not start. | 1. Fuel shut off valve on Main Fuel |
| ||||
|
| Filter in the OFF position. Open |
| |||
|
| valve (vertical) position of handle. |
| |||
| 2. | Fuel Filters dirty/clogged. Check |
| |||
|
| and replace main filter element |
| |||
|
| and/or Inline Fuel Filter. |
|
|
|
|
| 3. | Out of fuel. Fill tank and bleed fuel |
| |||
|
| system. |
|
|
|
|
| 4. | High coolant temperature or low |
| |||
|
| oil pressure. (indictor lights lit) |
| |||
|
| Check oil and coolant levels. Fill if |
| |||
|
| required. Check for loose or bro- |
| |||
|
| ken fan belt. |
|
| If all recommended possible | areas |
| 5. ON/OFF switch on for more then of misadjustment have | been | ||||
|
| 60 seconds before starting. The checked and the problem persists, | ||||
|
| ON/OFF switch will need to be Contact your local Lincoln | ||||
|
| switched off and turned back on. Authorized Field Service Facility. | ||||
| 6. | Electronic Governor Controller not |
| |||
|
| functioning properly. |
|
|
|
|
| 7. | Faulty fuel pump. Check for fuel |
| |||
|
| flow through filters. Contact autho- |
| |||
|
| rized local Engine Service Shop. |
|
Engine shuts down shortly after | 1. | High coolant temperature or low |
starting. |
| oil pressure. (indictor light lit) |
|
| Change oil and oil filters and fill to |
|
| proper level. Check and fill coolant |
|
| level. Check for loose or broken |
|
| fan belt. Start engine and look for |
|
| leaks. |
| 2. Faulty oil pressure switch or other | |
|
| engine component. Contact |
|
| authorized local Engine Service |
|
| Shop. |
| 3. Faulty Idler/Protection Board. |
CAUTION
If for any reason you do not understand the test procedures or are unable to perform the tests/repairs safely, contact your Local Lincoln Authorized Field Service Facility for technical troubleshooting assistance before you proceed.