TROUBLESHOOTING
Continued
WARNING: If you smell gas Shut off gas supply.
Do not try to light any appliance.
Do not touch any electrical switch; do not use any phone in your building.
Immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s instructions.
If you cannot reach your gas supplier, call the fire department.
IMPORTANT: Operating heater where impurities in air exist may create odors. Cleaning supplies, paint, paint remover, cigarette smoke, cements and glues, new carpet or textiles, etc., create fumes. These fumes may mix with combustion air and create odors. These odors will disappear over time.
| OBSERVED PROBLEM | POSSIBLE CAUSE | REMEDY | ||||
|
|
|
|
|
|
|
|
| Heater produces a clicking/ticking noise | 1. | Metal expanding while heating or | 1. | This is common with most heaters. | ||
| just after burner is lit or shut off |
| contracting while cooling |
| If noise is excessive, contact qual- | ||
|
|
|
|
| ified service person | ||
|
|
|
|
|
|
| |
| Heater produces unwanted odors | 1. | Heater burning vapors from paint, | 1. | Open window and ventilate room. | ||
|
|
| hair spray, glues, cleaners chemicals, |
| Stop using odor causing products | ||
|
|
| new carpet, etc. (see IMPORTANT |
| while heater is running | ||
|
|
| statement above) | 2. | Locate and correct all leaks (see | ||
|
| 2. | Gas leak. See WARNING |
| Checking Gas Connections, page | ||
|
|
| statement at top of page |
| 15) |
|
|
|
|
|
|
|
| ||
| Heater shuts off in use (ODS operates) | 1. | Not enough fresh air is available | 1. | Open window and/or door for | ||
|
|
|
|
| ventilation | ||
|
| 2. | Low line pressure | 2. | Contact local gas company | ||
|
| 3. | ODS/pilot is partially clogged | 3. | Clean ODS/pilot (see Cleaning | ||
|
|
|
|
| and Maintenance, page 19) | ||
|
|
|
|
|
|
| |
| Gas odor even when control knob is in | 1. | Gas leak. See WARNING | 1. | Locate and correct all leaks (see | ||
| OFF position |
| statement at top of page |
| Checking Gas Connections, page | ||
|
|
|
|
| 15) |
|
|
|
| 2. | Control valve defective | 2. | Replace control valve | ||
|
|
|
|
|
|
| |
| Gas odor during combustion | 1. | Foreign matter between control | 1. | Take apart gas tubing and remove | ||
|
|
| valve and burner |
| foreign matter | ||
|
| 2. | Gas leak. See WARNING | 2. | Locate and correct all leaks (see | ||
|
|
| statement at top of page |
| Checking Gas Connections, page | ||
|
|
|
|
| 15) |
|
|
22
