Manuals / Polaris / Lawn and Garden / Portable Generator

Polaris P2000i, P1000i manual No Power at DC Receptacle, Possible Lean Solution Fuel Cause

Models: P2000i P1000i

1 80

Download 80 pages 53.34 Kb

Page 70

		TROUBLESHOOTING
	Troubleshooting Symptoms

	POSSIBLE LEAN	SOLUTION
	FUEL CAUSE	SOLUTION
	FUEL CAUSE

	Low or contaminated fuel	Add fuel or drain the fuel system and refuel

	Kinked or plugged fuel tank	Inspect and replace
	vent

	Low octane fuel	Drain the fuel system and refuel

	Carburetor jetting incorrect	Take the generator to an authorized POLARIS servicing
		supplier or refer to the service manual


	POSSIBLE RICH	SOLUTION
	FUEL CAUSE	SOLUTION
	FUEL CAUSE

	Incorrect fuel / fuel is very	Drain the fuel system and refuel
	high octane

	Stopping / starting without	Allow the engine to warm up before operating and / or
	adequate warm-up	stopping

	Incorrect spark plug	Inspect and replace with correct spark plug

	Clogged air cleaner filter	Inspect and clean or replace

	No Power at DC Receptacle

	POSSIBLE CAUSE	SOLUTION

	DC circuit protector blown	Replace the fuse

	Faulty generator	Take the generator to an authorized POLARIS servicing
		supplier or refer to the service manual

69

Image 70

Polaris P2000i, P1000i manual No Power at DC Receptacle, Possible Lean Solution Fuel Cause

Contents

Polaris Power Table of Contents Introduction WelcomeIntended Use Safety Precautions Signal Words and Safety Terms Alcohol or Drug USEIdentification Numbers and Locations P1000iP2000iGeneral SafetySafety Warnings and Precautions Before and During OperationFire Safety Operator Safety Fuel Safety Carbon Monoxide Safety Electrical Safety Extension Cord Information Equipment ModificationsOutdoor Use only Danger Label Safety Labels and LocationsCarbon Monoxide Warning Hot Exhaust CautionSafety Controls and Features Generator ComponentsControl Panel Components P1000i P2000iFuel Tank Cap Vent Lever Engine Fuel SwitchChoke Lever Starter Recoil GripSmart Throttle Switch DC Receptacle and FuseGround Terminal Indicator PanelAC Receptacles Overload Protector Reset Switch Parallel ReceptaclesFirst USE Instructions Adding Engine OilFuel Recommendation Adding Fuel Pre-Operation Checklist PRE-OPERATION InspectionFuel Recommendations Safe Operating PrecautionsOperation RefuelingRemove the fuel tank cap a Before Starting the Engine Starting the EnginePosition the engine switch to on Stopping the Engine AC Operation AC Capacity Wattage Reference Table Power Management DC OperationOperation Disconnecting the Battery Charging Cable Smart Throttle SystemStandby Power Connections to a Building Electrical SystemParallel operation procedure Parallel Generator OperationShutting off the generators High Altitude Use Carburetor ModificationSource of Emissions Emission Control System InformationAlterations Problems Affecting Emissions Replacement PartsMaintenance Importance of MaintenanceMaintenance Safety Safety PrecautionsPeriodic Maintenance Periodic Maintenance ChartOpening the Service Door Hour Initial Break-In Initial MaintenanceFuel System Fuel Line InspectionOFF Oil Recommendation Engine OilOil Level Inspection Oil Change Procedure Maintenance Air Filters Air Filter InspectionAir Filter Cleaning Air Filter ReplacementSpark Plug Inspection and Replacement Spark PlugGap should be 0.6 0.7 mm Transportation Transportation and StorageTransporting the Generator Storage Storage PreparationAccessing the Fuel Tank Draining Fuel from the Fuel Tank and Carburetor Fogging the Engine Storage Precautions Removing from StorageSpecifications General SpecificationsPolaris Lubricants and Maintenance Products Modified coefficient table of ambient condition powerWiring Diagrams P1000i Wiring DiagramP2000i Wiring Diagram Red Gray Brown White BlackEngine Will Not Turn Over TroubleshootingTroubleshooting Symptoms Engine Turns Over, but Will Not StartEngine Lacks Power Engine BackfiresEngine Pings or Knocks Engine Runs Irregularly, Stalls, or MisfiresNo Power at DC Receptacle Possible Lean Solution Fuel CauseNo Power at AC Receptacles Engine Stops or Loses PowerWarranty About this Warranty Document Warranty Registration FormWarranty Period Warranty Exclusions Polaris Power Generator Owner Responsibility Important Notice Maintenance LOG DATE/HOURS Service Comments Supplier Permormed TechnicianIndex Label LocationIndex PMS