Problems Affecting Emissions, Replacement Parts | Polaris P1000i

OPERATION

Emission Control System Information

Problems Affecting Emissions

If aware of any of the following, have the engine inspected and repaired by an authorized POLARIS supplier:

•Hard starting or stalling after starting

•Rough idle

•Shut down or backfire after applying an electrical load

•Afterburning (backfiring)

•Black exhaust smoke or high fuel consumption

Replacement Parts

The emission control system on the engine was designed, built, and certified to conform to applicable emission regulations. We recommend the use of POLARIS Genuine parts whenever maintenance is performed. These original design replacement parts are manufactured to the same standards as the original parts. The use of replacement parts that are not of the original design and quality may impair the effectiveness of the emission control system.

Aftermarket part manufacturers assume the responsibility that the part will not adversely affect emission performance. The manufacturer or re- builder of the part must certify that use of the part will not result in a failure of the engine to comply with emission regulations.

42

Image 43

Polaris P1000i, P2000i manual Problems Affecting Emissions, Replacement Parts

Contents

Polaris Power Table of Contents Welcome Introduction Intended Use Safety Precautions Alcohol or Drug USE Signal Words and Safety Terms P1000iP2000i Identification Numbers and Locations Before and During Operation SafetySafety Warnings and Precautions General Fire Safety Operator Safety Fuel Safety Carbon Monoxide Safety Electrical Safety Equipment Modifications Extension Cord Information Hot Exhaust Caution Safety Labels and LocationsCarbon Monoxide Warning Outdoor Use only Danger Label Safety Generator Components Controls and Features P1000i P2000i Control Panel Components Starter Recoil Grip Engine Fuel SwitchChoke Lever Fuel Tank Cap Vent Lever DC Receptacle and Fuse Smart Throttle Switch Ground Terminal Indicator PanelAC Receptacles Parallel Receptacles Overload Protector Reset Switch Adding Engine Oil First USE Instructions Fuel Recommendation Adding Fuel PRE-OPERATION Inspection Pre-Operation Checklist Refueling Safe Operating PrecautionsOperation Fuel Recommendations Remove the fuel tank cap a Starting the Engine Before Starting the Engine Position the engine switch to on Stopping the Engine AC Operation AC Capacity Wattage Reference Table DC Operation Power Management Operation Smart Throttle System Disconnecting the Battery Charging Cable Connections to a Building Electrical System Standby Power Parallel Generator Operation Parallel operation procedure Shutting off the generators Carburetor Modification High Altitude Use Source of Emissions Emission Control System InformationAlterations Replacement Parts Problems Affecting Emissions Importance of Maintenance Maintenance Safety Precautions Maintenance Safety Periodic Maintenance Chart Periodic Maintenance Opening the Service Door Fuel Line Inspection Initial MaintenanceFuel System Hour Initial Break-In OFF Oil Recommendation Engine OilOil Level Inspection Oil Change Procedure Maintenance Air Filter Inspection Air Filters Air Filter Replacement Air Filter Cleaning Spark Plug Spark Plug Inspection and Replacement Gap should be 0.6 0.7 mm Transportation Transportation and StorageTransporting the Generator Storage Preparation Storage Accessing the Fuel Tank Draining Fuel from the Fuel Tank and Carburetor Fogging the Engine Removing from Storage Storage Precautions General Specifications Specifications Modified coefficient table of ambient condition power Polaris Lubricants and Maintenance Products P1000i Wiring Diagram Wiring Diagrams Red Gray Brown White Black P2000i Wiring Diagram Engine Turns Over, but Will Not Start TroubleshootingTroubleshooting Symptoms Engine Will Not Turn Over Engine Backfires Engine Lacks Power Engine Runs Irregularly, Stalls, or Misfires Engine Pings or Knocks Possible Lean Solution Fuel Cause No Power at DC Receptacle Engine Stops or Loses Power No Power at AC Receptacles About this Warranty Document Warranty Registration Form Warranty Warranty Period Warranty Exclusions Polaris Power Generator Owner Responsibility Important Notice DATE/HOURS Service Comments Supplier Permormed Technician Maintenance LOG Label Location Index Index PMS