Control Panel Components, P1000i P2000i | Polaris specs

CONTROLS AND FEATURES

Control Panel Components:

		T	K	T	U	K
	N		Q			Q
	N		R			Q
	M		R	N		R
			S	M		S
			S			S
	U		O			O
			O			O
		P			P
					P
		P1000i			P2000i

	ITEM	NOMENCLATURE		DESCRIPTION

	K	SMART Throttle Switch		Automatically reduces engine speed when
	K	SMART Throttle Switch		loads are shut off or disconnected
				loads are shut off or disconnected

	M	DC Fuse Protector		Protects DC charging circuit from overloads

	N	12V DC Receptacle		Charges 12V DC batteries

	O	Ground Terminal		Provides ground for non-conductive metal
	O	Ground Terminal		parts and receptacle ground terminals
				parts and receptacle ground terminals

	P	240V AC Receptacles		Provides two connections for properly rated
	P	240V AC Receptacles		AC appliances
				AC appliances

	Q	Output Indicator		Illuminates GREEN when the generator is
	Q	Output Indicator		operating normally
				operating normally

	R	Overload Indicator		Illuminates RED for appliance short circuits
	R	Overload Indicator		or overloads
				or overloads

	S	Low Oil Indicator		Illuminates RED prior to the oil level falling
	S	Low Oil Indicator		below a safe limit
				below a safe limit

	T	Overload Reset Switch		Resets the circuit after an AC overload

	U	Parallel Receptacles		For use with proper POLARIS Parallel kits

17

Image 18

Polaris manual Control Panel Components, P1000i P2000i

Contents

Polaris Power Table of Contents Introduction Welcome Intended Use Safety Precautions Signal Words and Safety Terms Alcohol or Drug USE Identification Numbers and Locations P1000iP2000i General SafetySafety Warnings and Precautions Before and During Operation Fire Safety Operator Safety Fuel Safety Carbon Monoxide Safety Electrical Safety Extension Cord Information Equipment Modifications Outdoor Use only Danger Label Safety Labels and LocationsCarbon Monoxide Warning Hot Exhaust Caution Safety Controls and Features Generator Components Control Panel Components P1000i P2000i Fuel Tank Cap Vent Lever Engine Fuel SwitchChoke Lever Starter Recoil Grip Smart Throttle Switch DC Receptacle and Fuse Indicator Panel Ground TerminalAC Receptacles Overload Protector Reset Switch Parallel Receptacles First USE Instructions Adding Engine Oil Fuel Recommendation Adding Fuel Pre-Operation Checklist PRE-OPERATION Inspection Fuel Recommendations Safe Operating PrecautionsOperation Refueling Remove the fuel tank cap a Before Starting the Engine Starting the Engine Position the engine switch to on Stopping the Engine AC Operation AC Capacity Wattage Reference Table Power Management DC Operation Operation Disconnecting the Battery Charging Cable Smart Throttle System Standby Power Connections to a Building Electrical System Parallel operation procedure Parallel Generator Operation Shutting off the generators High Altitude Use Carburetor Modification Emission Control System Information Source of EmissionsAlterations Problems Affecting Emissions Replacement Parts Maintenance Importance of Maintenance Maintenance Safety Safety Precautions Periodic Maintenance Periodic Maintenance Chart Opening the Service Door Hour Initial Break-In Initial MaintenanceFuel System Fuel Line Inspection OFF Engine Oil Oil RecommendationOil Level Inspection Oil Change Procedure Maintenance Air Filters Air Filter Inspection Air Filter Cleaning Air Filter Replacement Spark Plug Inspection and Replacement Spark Plug Gap should be 0.6 0.7 mm Transportation and Storage TransportationTransporting the Generator Storage Storage Preparation Accessing the Fuel Tank Draining Fuel from the Fuel Tank and Carburetor Fogging the Engine Storage Precautions Removing from Storage Specifications General Specifications Polaris Lubricants and Maintenance Products Modified coefficient table of ambient condition power Wiring Diagrams P1000i Wiring Diagram P2000i Wiring Diagram Red Gray Brown White Black Engine Will Not Turn Over TroubleshootingTroubleshooting Symptoms Engine Turns Over, but Will Not Start Engine Lacks Power Engine Backfires Engine Pings or Knocks Engine Runs Irregularly, Stalls, or Misfires No Power at DC Receptacle Possible Lean Solution Fuel Cause No Power at AC Receptacles Engine Stops or Loses Power Warranty About this Warranty Document Warranty Registration Form Warranty Period Warranty Exclusions Polaris Power Generator Owner Responsibility Important Notice Maintenance LOG DATE/HOURS Service Comments Supplier Permormed Technician Index Label Location Index PMS