Power Management, DC Operation | Polaris P1000i, P2000i manual

OPERATION

Safe Operating Precautions

Power Management

		RUNNING	ADDITIONAL
	DEVICE	RUNNING	STARTING (SURGE)
	DEVICE	(RATED) WATTS	STARTING (SURGE)
			WATTS
	Paint Sprayer	360	1080

	Radio	300	300

Total Running (Rated) Watts = 660

Additional Starting Surge Watts = 1380

Total Generator Output Required = 2040

Ensure the combined electrical rating of the powered device(s) do not exceed the maximum allowed by the generator. Never exceed the maximum power rating of the generator. Power levels between rated and maximum may be used for no more than 30 minutes.

DC Operation

Connecting the Battery Charging Cable (included)

The battery emits explosive hydrogen gas during normal operation. A spark or flame can cause the battery to explode with enough force to kill or cause serious injury. Wear protective clothing and eye protection when charging a battery.

Battery posts, terminals, and related accessories contain lead and lead components. Wash hands after handling.

The DC charging output is not regulated. The DC receptacle should only be used for charging 12V DC batteries.The 12V DC receptacle has no battery overcharge protection function. Do not overcharge the battery.

When using the DC output, position the SMART throttle switch to OFF. The DC receptacle may be used while the AC power is in use.

34

Image 35

Polaris P1000i, P2000i manual Power Management, DC Operation

Contents

Polaris Power Table of Contents Welcome Introduction Intended Use Safety Precautions Alcohol or Drug USE Signal Words and Safety Terms P1000iP2000i Identification Numbers and Locations Before and During Operation SafetySafety Warnings and Precautions General Fire Safety Operator Safety Fuel Safety Carbon Monoxide Safety Electrical Safety Equipment Modifications Extension Cord Information Hot Exhaust Caution Safety Labels and LocationsCarbon Monoxide Warning Outdoor Use only Danger Label Safety Generator Components Controls and Features P1000i P2000i Control Panel Components Starter Recoil Grip Engine Fuel SwitchChoke Lever Fuel Tank Cap Vent Lever DC Receptacle and Fuse Smart Throttle Switch AC Receptacles Indicator PanelGround Terminal Parallel Receptacles Overload Protector Reset Switch Adding Engine Oil First USE Instructions Fuel Recommendation Adding Fuel PRE-OPERATION Inspection Pre-Operation Checklist Refueling Safe Operating PrecautionsOperation Fuel Recommendations Remove the fuel tank cap a Starting the Engine Before Starting the Engine Position the engine switch to on Stopping the Engine AC Operation AC Capacity Wattage Reference Table DC Operation Power Management Operation Smart Throttle System Disconnecting the Battery Charging Cable Connections to a Building Electrical System Standby Power Parallel Generator Operation Parallel operation procedure Shutting off the generators Carburetor Modification High Altitude Use Alterations Emission Control System InformationSource of Emissions Replacement Parts Problems Affecting Emissions Importance of Maintenance Maintenance Safety Precautions Maintenance Safety Periodic Maintenance Chart Periodic Maintenance Opening the Service Door Fuel Line Inspection Initial MaintenanceFuel System Hour Initial Break-In OFF Oil Level Inspection Engine OilOil Recommendation Oil Change Procedure Maintenance Air Filter Inspection Air Filters Air Filter Replacement Air Filter Cleaning Spark Plug Spark Plug Inspection and Replacement Gap should be 0.6 0.7 mm Transporting the Generator Transportation and StorageTransportation Storage Preparation Storage Accessing the Fuel Tank Draining Fuel from the Fuel Tank and Carburetor Fogging the Engine Removing from Storage Storage Precautions General Specifications Specifications Modified coefficient table of ambient condition power Polaris Lubricants and Maintenance Products P1000i Wiring Diagram Wiring Diagrams Red Gray Brown White Black P2000i Wiring Diagram Engine Turns Over, but Will Not Start TroubleshootingTroubleshooting Symptoms Engine Will Not Turn Over Engine Backfires Engine Lacks Power Engine Runs Irregularly, Stalls, or Misfires Engine Pings or Knocks Possible Lean Solution Fuel Cause No Power at DC Receptacle Engine Stops or Loses Power No Power at AC Receptacles About this Warranty Document Warranty Registration Form Warranty Warranty Period Warranty Exclusions Polaris Power Generator Owner Responsibility Important Notice DATE/HOURS Service Comments Supplier Permormed Technician Maintenance LOG Label Location Index Index PMS